Dexter Laundry T-50X2 EXPRESS (Commercial) - Manual (Page 12)

SERVICING DRYER
CAUTION: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and
dangerous operation. Verify proper operation after servicing.
ATTENTION. Lors des opérations d'entretien des commandes, étiqueter tous les fils avant de les déconnecter. Toute
erreur de câblage peut être une source de danger et de panne.
DRYER PREVENTIVE MAINTENANCE (PM) REQUIREMENTS
MAKE SURE ALL POWER IS DISCONNECTED BEFORE
SERVICING MACHINE
DAILY
1. Clean lint screen using a soft brush if necessary. Check lint screen for rips or tears and replace if damaged.
MONTHLY
1. Clean lint from motor end bells and dryer controls area.
2. Clean lint from lint screen compartment.
3. Clean lint accumulation from top and all areas above, around and below burners and burner housing. Failure
to keep this section of dryer free from lint can create a fire hazard.
SEMI-ANNUALLY
1. Check V-belts for cracks, wear, fraying, or looseness.
2. Inspect all fasteners (screws, bolts, nuts, etc.) and tighten any that are loose.
3. Clean all lint accumulation from inside of front panel.
4. Place a few drops of light oil on top and bottom pivots of the door hinge.
5. Inspect door glass gasket for excessive wear.
6. Clean lint accumulation from the burner primary air ports.
7. Check intermediate drive pulley bushings for excessive wear.
ANNUALLY
1. Remove, inspect and clean main burner orifices of obstructions or dirt.
2. Grease intermediate drive pulley bearing at zirk grease fitting.
3. Inspect and remove any lint accumulation in the exhaust ducts. Inspect all ducting from the dryer exhaust
connection to the exit wall or roof.
4. Check tumbler shaft retaining nut for 125 Ft. pound torque.
SERVICE PARTS PART NUMBER
DRIVE BELT, MOTOR 9040-076-009
DRIVE BELT, TUMBLER 9040-073-011
LINT SCREEN FILTER 9555-057-008
For service and parts information contact your local Dexter agent. If a Dexter agent is not available, contact
Dexter Laundry, Inc. directly as listed below:
Mailing Address:
2211 West Grimes Avenue Phone: 1 + 641-472-5131 (USA)
Fairfield, IA 52556 Fax: 1 + 641-472-6336 (USA)
USA
Website:
www.dexter.com/laundry/
12