Document Outline

• Cover of Manual
• System Specifications
  • Output
  • Input
  • Connections
  • Environmental
  • Miscellaneous
  • Safety
  • Other Referenced Standards
• CXCM2 Specifications
  • Basic Unit, CXCM2
  • Environmental
  • Hardware Specifications, CXCM2
  • Recommended Signal Wire Sizes (as per UL/CSA)
• Important Safety Instructions
• Body of Manual
  • Introduction
    • Scope of the Manual
    • Product Overview
    • System Configurations
    • Part Numbers and List Options
  • Features
    • System Overview
    • Distribution Center
      • Distribution Configurations
      • Low Voltage Battery Disconnect (LVBD)
      • Shunt
      • Internal Alarm Card
      • CXCM2 I/O Terminal Block
    • CXCM2 Features
      • System Controller Front Panel
      • LEDs
        • Alarm Conditions
        • Progress and Status Indication
      • Reset
      • Ethernet Port
      • Analog Input Channels
        • Voltage Inputs
        • Current Inputs
        • Temperature Inputs
      • Digital Input Channels
      • Alarm and Control Output Relays
      • Network Connection and Remote Communications
    • Cordex 48-1.8kW Rectifier
      • LEDs
        • AC
        • DC
        • ALARM
        • LED Activity During Software Upload
        • LED Activity During ‘Locate Module’ Command from CXC
      • Mechanical
      • Rear Panel
      • True Module Fail Alarm
      • Heat Dissipation
      • Over Temperature Protection
      • Wide AC Range
      • AC Inrush/Transient Suppression
      • Soft Start
      • Start Delay
      • Current Limit/Short Circuit Protection
      • Power Limiting
      • High Voltage Shutdown (HVSD)
      • Battery Eliminator Operation
  • Inspection
    • Packing Materials
      • Returns for Service
    • Check for Damage
    • General Receipt of Shipment
      • Racks
      • Rectifiers (Purchased Separately)
      • Miscellaneous Small Parts
      • Batteries (Purchased Separately)
  • Installation
    • Safety Precautions
    • Tools Required
    • Power System Assembly and Mounting
      • Rack Mounted Systems
      • Floor Mounted Systems
    • Rectifier Module Insertion/Removal
    • Breaker Installation
    • Breaker Removal
    • Battery Installation
      • Preparation/Mounting
      • Installation of Batteries
  • Wiring
    • Grounding
      • Frame Ground
    • AC Feeder Protection/Sizing
    • AC Input Connections
    • Calculating Output Wire Size Requirements
    • DC Output Connections
    • System and Battery Connections
      • DC Input to Panel
      • Distribution Cabling
      • Breaker Output (Hot) Connections
      • Breaker Return (Ground) Connections
      • Battery Breaker Connections
    • Alarm Connections
    • CAN Serial Ports
      • CAN Termination
    • Network Connection and Remote Communications via CXC
      • Ethernet Port for Network Connection (Standard Network Cable
      • Ethernet Port for Local Connection (Crossover Cable)
    • Signal Wiring Connections for CXCM2
      • Alarm (Relay) Outputs
      • Digital Inputs for CXCM2
        • Connection Method
        • Programming the Digital Input
      • Analog Inputs
        • Voltage
        • Temperature Sensor
        • Current
  • System Startup
    • Check System Connections
    • Verify AC and Power the Rectifier Shelf
    • Check Battery Polarity and Connect
      • CXC Alarm Configuration for Nominal 120Vac Operation
    • CXCM2 Reset
      • Soft Reset
    • LVD Control
  • Operation
    • Main Rectifier States
      • Off State
      • Start Delay State
      • Soft Start State
      • Normal Operation State
      • Turning Off State
    • Main Rectifier Modes
      • Output Voltage Modes
      • Output Current/Power Modes
    • Factory Ranges and Defaults
  • Maintenance
    • Fan Replacement
    • MOV Replacement
    • CXCM2 Replacement (as used with 1.8kW shelf)
  • Argus Conventions
    • Numbering System
    • Acronyms and Definitions
• Outline Drawing
• Schematic, Power System
• Customer Connections
• Warranty and Service
• Service Centers
• 053991b1a__specs_new.pdf
  • Output
  • Input
  • Connections
  • Environmental
  • Miscellaneous
  • Safety
  • Other Referenced Standards