JELD-WEN JII006 Vinyl Patio Doors with Integral Nailing Fin - Manual (Page 7)

INSTALLATION INSTRUCTIONS
for Vinyl Patio Doors with Integral Nailing Fin (JII006)
7
PATIO DOOR ADJUSTMENT
Roller Adjustment
Note!
Adjusting door
too high may allow
water and air leakage.
Adjust rollers just
high enough to clear
sill track and still
roll smoothly.
1. Builders doors have
an adjustment
screw on each
lower end of the
operating panel(s).
Premium doors
have access holes
on the face of each
lower end of the
operating panel(s).
Remove small vinyl
plugs from each
hole (if present).
2. Open operating
panel enough to
expose a 1/4"gap
between the panel
and frame jamb.
Verify the gap is
even along entire
height of panel to
frame. If uneven,
adjust by referring
to the following steps.
Lock Adjustment
Note!
If the strike
plate was not
previously installed,
line up the screw
holes with the dimples
in the operating
panel side jamb and
drive screws through
the two slotted
screw holes.
If the lock does not
properly engage the
strike plate:
• Loosen the strike
plate screws and
move up or down
until the latch
engages properly.
If the door does
not lock or is loose
when locked:
• Turn the latch
adjustment
screw(s) in 1/2
turn increments:
clockwise to loosen
or counterclockwise
to tighten. Premium
doors have a double
latch and two
adjustment screws.
Premium Patio Door
Builders Patio Door
Note! Builders roller adjustment screws are in close proximity to the
attachment screw. Adjust only the lower screw (as shown); loosening
the attachment screw will detach the roller from the operating panel.
3. Using a #2 Philips
head screwdriver,
turn the adjustment
screw clockwise to
raise the panel, and
counterclockwise to
lower the panel.
4. Adjust as needed
until interlocks, grid
patterns, and jambs
line up.
5. Test the operating
panel for proper
operation.
6. Re-apply the small
vinyl caps over the
roller adjustment
screw holes if
applicable.
Attachment
screw
Adjustment
screw
Lower panel
Raise panel
Builders Roller
Premium Patio Door
Lock hook
adjustment screw
Lock hook
adjustment screw
Builders Patio Door
Lock hook
adjustment
screw
Strike
plate
COMPLETE INSTALLATION - CONTINUED
7