JELD-WEN JII006 Vinyl Patio Doors with Integral Nailing Fin - Manual (Page 8)

INSTALLATION INSTRUCTIONS
for Vinyl Patio Doors with Integral Nailing Fin (JII006)
8
Please visit jeld-wen.com for warranty
and care and maintenance information.
Thank you for choosing
©2014 JELD-WEN, inc.; This publication and its contents are owned by JELD-WEN, inc. and are protected under the U.S. Copyright Act and other intellectual
property laws. All trademarks, service marks, logos and the like (whether registered or unregistered) are owned or controlled by JELD-WEN, inc. or others.
Unauthorized use or duplication of JELD-WEN intellectual property is prohibited.
JELD-WEN reserves the right to change product specifications without notice. Please check our website, jeld-wen.com, for current information. (07/14)
FINISH INSTALLATION
1. Drive two
#10 x 2 1/2"
screws (included
in hardware pack)
through the open
screw holes in the
strike plate.
2. Remove the pre-
installed screws
from the strike plate
and replace them
with the remaining
#10 x 2 1/2" screws
from the hardware
pack. This will
increase security
by attaching the
patio door to
the structure.
CONTINUOUS AIR SEAL
Create a continuous air seal on the interior between the rough opening
and the door frame with backer rod and sealant or low expansion foam.
Allow the foam to fully cure and cut flush with a sharp knife. Make sure
the foam cuts cleanly and doesn’t tear.
AFTER INSTALLATION
1. Install exterior
wall surface per
manufactures’
guidelines.
2. Seal any gaps or
openings at end of
horizontal mull joints
with sealant.
3. Leave an expansion/
contraction gap
of approximately
3/8" between door
frame and final
exterior wall surface
(siding, stucco,
etc.). For a finished
look and additional
protection, seal this
gap on the sides
with backer rod and
sealant. If sealant
is applied above
the drip cap ensure
the sealant bead
is discontinuous to
allow for drainage.
4. Protect recently
installed units
from damage from
plaster, paint, etc.
by covering the unit
with plastic.
Premium Patio Door
Replacement
screw
Pre-installed
screw
Pre-installed
screw
Builders Patio Door
Pre-installed
screw
Replacement
screw
Pre-installed
screw
Backer rod
Gap
Rough
opening
Door
frame
Sealant joint
Gap
COMPLETE INSTALLATION - CONTINUED
7