NaceCare Solutions TTV5565 - Manual (Page 24)

24
Failure to rectify the problem or in the event of a breakdown
contact your Nacecare dealer or the Nacecare Technical
helpline +44 (0) 900 1 905 785 0038
PROBLEM CAUSE SOLUTION
Machine will not operate Missing or blown fuses
Key in the ‘Off’ position
Low battery charge
Machine is connected and charging
Waste tank full switch stuck or clogged Fit or replace fuse (page 8)
Turn key to ‘On’ position (page 8)
Charge batteries (page 20)
Take off charge (page 20)
Inspect and clean switch (page 15/18)
Vacuum will not operate Waste-water tank full Empty waste water tank (page 18)
Poor water pick-up Waste-water tank full
Clogged / blocked vacuum hose
Loose hose connections
Debris basket filter clogged / blocked
Separator filter clogged / blocked
Poor separator seal
Damaged separator seal
Damaged / split vacuum hose
Damaged floor-tool blades
Low battery charge Empty waste-water tank (page 18)
Remove and clean (page 18)
Push tight connections (page 18)
Remove and clean (page 18)
Remove and clean (Page 18)
Clean and refit (page 18)
Renew (contact service dept)
Renew (contact service dept)
Renew (contact service dept)
Recharge batteries (page 20)
No brush / Scrub function No brushes fitted
Brush deck raised Check and fit (page 10)
Lower brush deck (page 13)
Little or no water flow Clean-water tank empty
Clean-water tank filter blocked / clogged
Incorrect water flow setting
Brush deck raised Fill clean-water tank (page 11)
Remove and clean (18)
Adjust as desired (Page 14)
Lower brush deck (page 13)
Little or no dosing solution flow Chemical dosing tank empty
incorrect dosing flow setting Fill dosing-tank (page 12)
Adjust as desired (page 14)
Machine just ‘stops’ while
operating Too much load on the brush system Reset the machine using the key and
decrease the brush load to best suit
the floor type (page 15. Fig.23)
303641 Bottom TankDump hose assembly (clean water)
213047 Top Tank Waste water emptying hose
208335
Floor tool hose assembly
577697 Separator hood assembly
206265
Barrel filter
208417 Trash basket
237173 Trash basket lid
391319
Separator gasket
303953 Filling cap & hose assembly
208307 Brush deck skirt (long)
208324 Brush deck skirt (short)
208167 Spare key (x2)
Trouble-Shooting
Recommended Spare Parts
Nacecare Helpline