ARB 3450120 - Manual (Page 6)

29/8/05 Page 6 of 12 3783172
14. When front bolts are tight, loosen off lower
bolts in chassis brackets. Using a 10mm drill
bit, drill out the most rearward hole in lower
chassis bracket being careful not to drill too
far into captive nut channel. When holes have
been drilled, realign the rear hole with rear
nut in captive nut channel, and secure using
10mm hardware, then lightly tighten all bolts
in lower chassis brackets.
MOUNTING SYSTEM MUST BE ABLE TO
BE MOVED SIDEWAYS.
Vehicle Park Loom
15. If the vehicle is fitted with fog lights in the
grill, as shown in diagram 1, the fog loom will
need to be extended. First, cut the 1.3m red
wire, supplied in the kit, into four equal
lengths (i.e. 325mm each) and then cut the
plug off the vehicle’s fog loom. Use the four
pieces of wire just cut together with the scotch
locks to lengthen the vehicle’s fog loom and re-
connect the plugs. Once this task has been
completed for both the LH & RH fog lights,
refit the grill to the vehicle and allow the fog
looms to hang out through the fog apertures.
16. To fit the turn signal / park light loom first
unplug the loom going into the park light in
the headlamp. This is the lower small plug on
the lower half of the head light. Disconnect
this clip by first pulling the red lever back then
push the black tab (behind the red lever) down
and pull the clip apart. Remove the plastic
sleeve from the loom supplied and then use a
plastic scotch lock to connect red wire
(supplied loom) to the yellow / black wire
(passenger side) or the yellow / green wire
(drivers side) of the vehicle park light loom.
Once this connection has been made reconnect
vehicle’s loom into the park light and feed the
new loom behind and below the headlight.
Next use scotch locks to connect the remaining
two wires to the vehicle’s blinker loom.
Summary of Wire Connections
VEHICLE PARK LAMP FUNCTION TURN
SIGNAL
HARNESS
RIGHT LEFT
PARK LAMP RED GREEN /
YELLOW
YELLOW /
BLACK
VEHICLE INDICATOR
RIGHT LEFT
EARTH BLACK BLACK BLACK
INDICATOR GREEN RED RED