SkyTrak 3606 Service Manual - Manual (Page 391)

Electrical System
10-73 Model 3606 • Origin 10/99
10.8.17 Steering
Certain steering functions are dependent upon electrical
operations, described below. Consult the Owners/Opera-
tors Manual for further information related to steering.
Four Wheel Steer Indexing
If the vehicle does not drive “straight,” the steering could
not be synchronized or “out of phase.” Perform the Four
Wheel Steer Indexing procedure to synchronize the
steering.
Four Wheel Steer Indexing Procedure
1. With the steering select switch (Fig. 10– 87) in the
four wheel steer position, turn the steering wheel fully
left.
2. While holding the steering wheel fully left, toggle the
steer select switch to the front wheel steer position.
3. Steer the front wheels back to center.
4. Toggle the steer select switch back to four wheel
steer position.
5. Turn the steering wheel fully left.
6. Toggle the steering select switch back to the front
wheel steering position.
7. Steer the front wheels fully left.
8. Toggle the switch to the four wheel steer position and
return to center.
The vehicle should now be properly indexed in four wheel
steering. If the steering is still not synchronized, repeat
the procedure.
a. Steering Select Switch
The steering select switch (Fig. 10– 86 and Fig. 10– 87) is
located on the right console to the rear of the joystick
below the armrest. It is a three-position switch that is
pressed or “snapped” into a rectangular switch bezel.
Figure 10– 86. Location of various operational controls.
Figure 10– 87. Steering select switch.
This three-position switch is a single-pole, double throw
toggle switch that has three positions (Fig. 10– 87 and
Fig. 10– 88). It has a multiple-connector plug on its under-
side that connects to the cab wiring harness. Wiring from
the plug connects the switch with power from the fuse
panel bus bar, and to the operators display panel and the
steering select solenoids on the vehicle.
OS0402
Joystick
Bezel
Steering Selection
Indicators Travel and Gear
Select Lever
Bezel
Parking Brake
Switch
Attachment Tilt
Mode Switch
Steering Select
Switch
OS1411
STEERING
SELECTION
INDICATORS
FOUR
WHEEL
STEERING
FRONT
WHEEL
STEERING
CRAB
STEERING
STEERING
SELECT
SWITCH