JLG 110HX Service Manual - Manual (Page 19)

SECTION 1 - SPECIFICATIONS
3120864 – JLG Lift – 1-7
Table 1-9. Lubrication Chart
Components
Number/Type
Lube Points
Lube & Method
Interval
Hours
Comments
1 Master Cylinder - Barrel End 1 Grease Fitting MPG - Pressure Gun 150 Remote Access
2 Master Cylinder - Rod End 1 Grease Fitting MPG - Pressure Gun 150
3 Boom Pivot Bushings 2 Grease Fittings MPG - Pressure Gun 150
4 Lift Cylinder - Rod End 1 Grease Fitting MPG - Pressure Gun 150
5 Lift Cylinder - Barrel End 1 Grease Fitting MPG - Pressure Gun 150 Remote Access
6 Slave Cylinder - Rod End 1 Grease Fitting MPG - Pressure Gun 150
7 Slave Cylinder - Shaft End 1 Grease Fitting MPG - Pressure Gun 150
8 Extend-A-Reach Cylinder - Rod End 1 Grease Fitting MPG- Pressure Gun 150
9 Extend-A-Reach Cylinder - Attach Pin 2 Grease Fittings MPG - Pressure Gun 150
10 Platform Door Hinges 2 Grease Fittings MPG - Pressure Gun 150
11 Platform Door Latch N/A SAE10 - Oil Can 150
12 Rotary Platform Control Stand 2 Grease Fittings MPG - Pressure Gun 150
13 Platform Attach Pin and Rotary Worm
Gear 1 Grease Fitting Each MPG - Pressure Gun 150
14 Drive Hubs Fill Plug EPGL - SAE90 150/1200 Check every 150 hrs. /Change every 1200 hrs.
15 Swing Bearing Gear N/A MPG - Brush 150
16 Swing Bearing 1 Grease Fitting MPG - Pressure Gun 150
17 Steer Spindles 2 Grease Fittings MPG - Pressure Gun 150
18 Steer Cylinder - Rod End 1 Grease Fitting MPG - Pressure Gun 150
19 Steer Cylinder - Barrel End 1 Grease Fitting MPG - Pressure Gun 150
20 Tie Rod Ends 2 Grease Fittings MPG - Pressure Gun 150
21 Extending Axle Beams N/A MPG - Brush 150
22 Wheel Bearings N/A MPG - Repack 1200
23 Engine Crankcase Fill Cap EO-SAE30 10/300 Check daily/Change every 300 hrs.
24 Engine Oil Filter N/A Replaceable Cartridge 300
25 Door and Access Panel Hinges N/A SAE10 - Oil Can 150
26 Hydraulic Fluid Fill Cap HO 10/1200 Check daily/Change every 1200 hrs.
27 Hyd. Filter Element (Tank) N/A N/A 50/300 Replace filter after first 50 hrs. of operation,
then every 300 hrs. thereafter
28 Hyd. Filter Element (Inline) N/A N/A 50/300 Replace filter after first 50 hrs. of operation,
then every 300 hrs. thereafter
29 Telescope Cylinder Sheave 1 Grease Fitting MPG - Pressure Gun 150
30 Extend Chain Sheave 1 Grease Fitting MPG - Pressure Gun 150
31 Retract Chain Sheave 1 Grease Fitting MPG - Pressure Gun 150