Rockwell Automation SB3000 Universal Drive Controller Module - Manual (Page 19)

Installation 3-1
C
HAPTER
3
Installation
This chapter describes how to install and replace the UDC module. Refer to the
appropriate Distributed Power System Diagnostics, Troubleshooting, and Start-Up
Guidelines instruction manual for system connection instructions.
3.1 Wiring
The installation of wiring should conform to all applicable codes. To reduce the
possibility of noise interfering with the control system, exercise care when installing
wiring from the system to external devices. For detailed recommendations, refer to
IEEE Standard 518.
3.2 Initial Installation
Use the following procedure to install the module:
Step 1. Stop any application tasks that may be running.
Step 2. Turn off power to the system. All power to the rack, as well as all power to the
wiring leading to the rack, should be off.
Step 3. Take the module out of its shipping container. Take it out of its anti-static bag,
being careful not to touch the connector on the back of the module. Save the
anti-static bag in a safe place. The module must be stored in an anti-static
bag whenever it is not installed in the rack.
!
$77(17,21 2QO\ TXDOLILHG HOHFWULFDO SHUVRQQHO IDPLOLDU ZLWK WKH
FRQVWUXFWLRQ DQG RSHUDWLRQ RI WKLV HTXLSPHQW DQG WKH KD]DUGV LQYROYHG
VKRXOG LQVWDOO DGMXVW RSHUDWH DQGRU VHUYLFH WKLV HTXLSPHQW 5HDG DQG
XQGHUVWDQG WKLV PDQXDO DQG RWKHU DSSOLFDEOH PDQXDOV LQ WKHLU HQWLUHW\
EHIRUH SURFHHGLQJ )DLOXUH WR REVHUYH WKLV SUHFDXWLRQ FRXOG UHVXOW LQ
VHYHUH ERGLO\ LQMXU\ RU ORVV RI OLIH
$77(17,21 7KH XVHU LV UHVSRQVLEOH IRU FRQIRUPLQJ ZLWK DOO DSSOLFDEOH
ORFDO QDWLRQDO DQG LQWHUQDWLRQDO FRGHV )DLOXUH WR REVHUYH WKLV SUHFDXWLRQ
FRXOG UHVXOW LQ GDPDJH WR RU GHVWUXFWLRQ RI WKH HTXLSPHQW
$77(17,21 ,QVHUWLQJ RU UHPRYLQJ D PRGXOH PD\ UHVXOW LQ XQH[SHFWHG
PDFKLQH PRWLRQ 3RZHU WR WKH PDFKLQH VKRXOG EH WXUQHG RII EHIRUH
LQVHUWLQJ RU UHPRYLQJ D PRGXOH )DLOXUH WR REVHUYH WKHVH SUHFDXWLRQV
FRXOG UHVXOW LQ ERGLO\ LQMXU\
!
$77(17,21 7KLV HTXLSPHQW LV DW OLQH YROWDJH ZKHQ $& SRZHU LV
FRQQHFWHG GLVFRQQHFW DQG ORFN RXW DOO XQJURXQGHG FRQGXFWRUV RI WKH $&
SRZHU OLQH )DLOXUH WR REVHUYH WKHVH SUHFDXWLRQV FRXOG UHVXOW LQ VHYHUH
ERGLO\ LQMXU\ RU ORVV RI OLIH