Document Outline

• Seed and Fertilizer Rate Charts for the YP3025A, YP4025A and YP4425A 30, 40 and 44-Foot 3-Section Yield-Pro® Planters with Air-Pro® seed meters
• Table of Contents
• Introduction
  • Models Covered
    • YP4425A
    • YP4025A
    • YP3025A
  • Document Family
    • DICKEY-john® IntelliAg® manuals
    • Quick Start Guides (QSG)
• Rate Setting Overview
  • Setting Planting Rate
  • Setting Fertilizer Rate
  • Population Reference Information
    • Kernels Per Pound
    • Seeds per Unit
    • Seed Spacing
      • Spacing (U.S. Customary units, page 1 of 2)
      • Spacing (U.S. Customary units, page 2 of 2)
  • Air-Pro® Meter Disk Selection
  • Meter Pressurization
    • Corn: Reading a Pressure Chart (below, next page)
    • Initial Meter Pressurization: Canola and Cotton
    • Initial Meter Pressurization: Milo
    • Initial Meter Pressurization: Soybeans
    • Initial Meter Pressurization: Sunflower
    • Initial Meter Pressurization: Volumetric
    • Initial Meter Pressurization: Flat Corn
    • Factory Default Air Control Channel Screens
      • Material 16 Setup
      • Control Channel 2 Setup
  • Checking Planting Rate
    • Checking Singulated Rates
• Planting Rate
  • Hydraulic Drive Meter Rate
  • Meter RPM Limit Charts
    • Meter RPM Limits: Corn 24 Cell
    • Meter RPM Limits: Corn 40 Cell
    • Meter RPM Limits: Cotton 60 Cell
    • Meter RPM Limits: Milo 65 Cell
    • Meter RPM Limits: Milo 130 Cell
    • Meter RPM Limits: Soybeans 84 Cell
    • Meter RPM Limits: Soybeans 168 Cell
    • Meter RPM Limits: Sunflower 24 Cell
• Sprocket Indexing (Stagger)
  • Indexing Preparation
  • Basic Indexing
  • Indexing Fine Adjustment
    • Indexing Adjustment Steps
  • Sprocket Indexing Charts
    • Twin Row Sprocket Indexing (1 of 3)
    • Twin Row Sprocket Indexing (2 of 3)
    • Twin Row Sprocket Indexing (3 of 3)
• Canola Seeding
  • General Information
  • Related Documents
    • DICKEY-john® IntelliAg®
  • Pre-Requisites
  • Prepare Meters
  • Loading Seed
  • Configure Monitor
    • Material Setup
      • Material Setup: Hydraulic Drive
      • Air-Pro® Meter RPM Limits: Canola
    • Channel Setup: Hydraulic Drive
    • Row Monitor Setup
  • Canola Field Update
    • Tools Required
    • Update Brushes
    • Loosen Meter
    • Update Seed Tube
• Volumetric Seeding
  • General Information
  • Related Documents
    • DICKEY-john® IntelliAg®
  • Clean-Out Meters
  • Check or Install Grain Shield
  • Install Discs / Set Shutters
  • Take Note of Meter Pressure
    • Initial Meter Pressurization: Wheat
    • Initial Meter Pressurization: Rice
  • Calibrate
  • Furrow Checking Rate
  • IntelliAg® Hydraulic Drive
    • Set Up A Material
      • Material Setup
      • Channel Setup
    • Calibrate Speed Sensor
    • Meter RPM Limits - Volumetric
      • RPM Limits: Rice
      • RPM Limits: Wheat
• Fertilizer Rate
  • Fertilizer Rate Steps
  • Orifice Plate Selection
    • Determine Orifice Size
    • Install Orifice Plates
    • Row Shutoff
  • Strainer
    • Setting Relief Valve
  • Ground Drive Fertilizer Rate
    • JohnBlue Pump Rate
    • YP30A CDS-John Blue Fertilizer Rates
    • YP30A JohnBlue Reference Data
    • YP40A CDS-John Blue Fertilizer Rates
    • YP40A JohnBlue Reference Data
    • YP44A CDS-John Blue Fertilizer Rates
    • YP44A JohnBlue Reference Data
• Appendix A - Seed Lubricant
  • Seed Lubricants
• Appendix B - Metric Charts
  • Air-Pro® Disk Selection - Metric
  • Recommended Seed Disks, Metric (2 of 3)
  • Recommended Seed Disks, Metric (3 of 3)
  • Seed Spacing - Metric
  • Seed Spacing - Metric (cont.)
  • Meter Pressurization - Metric
    • Corn: Reading a Pressure Chart (below, next page)
    • Initial Meter Pressurization: Canola and Cotton
    • Initial Meter Pressurization: Milo
    • Initial Meter Pressurization: Soybeans
    • Initial Meter Pressurization: Sunflower
    • Initial Meter Pressurization: Sunflower
    • Initial Meter Pressurization: Flat Corn
  • Furrow Check - Metric
  • Meter RPM Limits - Metric
    • Meter RPM Limits: Corn 24 Cell
    • Meter RPM Limits: Corn 40 Cell
    • Meter RPM Limits: Cotton 60 Cell
    • Meter RPM Limits: Milo 65 Cell
    • Meter RPM Limits: Milo 130 Cell
    • Meter RPM Limits: Soybean 84 Cell
    • Meter RPM Limits: Soybean 168 Cell
    • Meter RPM Limits: Sunflower 24 Cell
  • Sprocket Indexing - Metric
    • 70 cm Twin Row Sprocket Indexing
    • 70 cm Twin Row Sprocket Indexing (cont.)
    • 75 cm Twin Row Sprocket Indexing
• Volumetric - Metric Charts
  • Volumetric Furrow Check - Metric
  • Volumetric Meter RPM Limits - Metric
    • Rice RPM Limits (metric)
    • Wheat RPM Limits (metric)