Dustless DustDroid 600 - Manual (Page 8)

dustlesstools.com 800.568.3949
8
DustDroid™ 600 & DustPro™ 600 HEPA Industrial Vacuums
The red hose (inside of filter)
and the black hose (outside of
filter) are equipped with
quick disconnect hose connec-
tions. In order to disconnect
them simply push in metal
collar and pull hose. To recon-
nect, simply push hose into
fitting. It will lock in place.
Secure latches on reservoirs.
The hook latches are adjust-
able. Occasionally adjust
the tension on the latches to
insure the seal is adequate on
the tanks.
Attach small vac hose from to
both reservoirs. If not using a
bag remove the hose
and block off both ports during
operation.
Description of the Machine __________________________________________________________
The Dustless Model 600 is a dust collection system with two independent vacuum motors that run on 120 volts 50/60 HZ. They may
be ran off of a 120/240 volt split power supply or off of two independent 120 volt 15 amp circuits.
There is an on board cyclone separator that collects most of the dust during operation. A small percentage of dust will then be col-
lected in the reservoir that is located beneath the motor housings. Both of these reservoirs are designed to be used with a plastic
trash bag in place for ease of disposal.
There are also two independent filter cleaning mechanisms that are built into the bottom of the motor housing.
Scope of Supply ___________________________________________________________________
Provided with machine:
• Dustless – Model 600 • Manual (1) • 2.5“ hose included, the 3” hose is optional
Setup Instructions __________________________________________________________________
Install sample plastic collection bag (included) into main reservoir and filter reservoir with bag
excess gathered and draping over edge of tank.
DO NOT RUN UNIT WITHOUT THe BAGS IN PLACe AS THIS WILL ALLOW DUST TO Be PULLeD
DIReCTLY INTO THe MOTOR AND WILL FLOW OUT OF THe eXHAUST THeReBY CONTAMINATe
THe WORK eNvIRONMeNT!
If bags are not available then remove the small 3/4” equalizer vacuum hoses from the sides of the
reservoirs and tape off both the hose and the hose port on the connectors. This will allow for nor-
mal operation except that the operator will then have to dump the dust collected in the reservoirs.
General Information
USe ONLY HeAvY DUTY BAGS! Thin bags may pull into the cyclone during operation.