AERCO KC1000 Heater 2002 User Manual
Kc series gas fired water heating system
Advertising
Printed in U.S.A.
REVISED 12/10
AERCO International, Inc.
• 159 Paris Ave. • Northvale, New Jersey 07647 • Phone: 201-768-2400 • FAX: 201-768-7789
KC Series Gas Fired Water Heater
GF-111
OMM-xxxx-xx
Operation and Maintenance Manual
Applicable to Serial Numbers G-02-530 and above
KC Series
Gas Fired
Water Heating
System
Natural Gas or Propane Fired,
Condensing and Forced Draft Hot Water Heater
1,000,000 BTU/HR Input
Patent No. 4,852,524
Advertising
Table of contents
Document Outline
- KC-H-Cover-JAN-09_PN
- KC-H-TOC-3-19-07
- FOREWARD A
- Section 1 – SAFETY PRECAUTIONS 1-1
- Section 2 – INSTALLATION PROCEDURES 2-1
- Section 3 – CONTROL PANEL OPERATING PROCEDURES 3-1
- Section 4 – INITIAL START-UP 4-1
- Section 5 – SAFETY DEVICE TESTING PROCEDURES 5-1
- Section 6 – MAINTENANCE 6-1
- Section 7 – TROUBLESHOOTING 7-1
- APPENDICES
- WARRANTIES W-1
- KC-H-Foreward-10-2-06-J
- KC-H-CH1-1-15-07-J
- KC-H-Ch2-11-25-08
- KC-H-Ch3-11-25-08
- KC-H-Ch4-11-25-08
- KC-H-Ch5--2-26-07
- KC-H-Ch6-GF111_12-09-10
- 6.1 MAINTENANCE SCHEDULE
- 6.2 Spark Ignitor
- 6.3 Flame Detector
- 6.4 COMBUSTION CALIBRATION
- 6.5 SAFETY DEVICE TESTING
- 6.7 BTU TRANSMITTER ASSEMBLY
- 6.8 MANIFOLD AND EXHAUST TUBES
- 6.9 HEAT EXCHANGER INSPECTION AND CLEANING
- 6.10 CONDENSATE DRAIN ASSEMBLY
- 6.11 LOW WATER CUTOFF PROBE INSPECTION AND CLEANING
- 6.12 HYDRAULIC ZERO NEEDLE VALVE ADJUSTMENT (C-More Control BOX)
- 6.13 FLAME STRENGTH MEASURMENT
- KC-H-Ch7_09-29-10
- SECTION 7- TROUBLESHOOTING GUIDE
- 1. Inspect feed forward (BTU transmitter) sensor for loose or broken wiring.
- 2. Check resistance of sensor to determine if it is within specification.
- 1. Measure the actual exhaust temperature and continuity of the exhaust sensor. If the exhaust temperature is less than 500 o F and the exhaust sensor shows continuity replace the sensor.
- 2. If exhaust temperature is greater than 500 o F, check combustion calibration. Calibrate or repair as necessary.
- KC1000 WATER HEATER TROUBLESHOOTING TABLE – Continued
- KC1000 WATER HEATER TROUBLESHOOTING TABLE – Continued
- KC1000 WATER HEATER TROUBLESHOOTING TABLE – Continued
- KC-H-App-A-11-25-08
- KC-H-App-B
- KC-H-App-C
- KC-H-App-D-JULY-06
- KC-H-App-E--4-25-07-A
- KC-H-App-F-11-30-06
- KC-H-App-G-JULY-06
- KC-H-App-H-12-27-08
- KC-B-App-I-12-27-08
- KC-HTR-WARRANTY