DR Power 5.00 HP Power Wagon - Manual (Page 21)

DR POWERWAGON 5.0 Safety & Operating Instructions 18
Figure 11
Lubrication
Your DR POWERWAGON 5.0 was lubricated at the Factory. The transmission is
lubricated for life with 16 ounces of 90-weight gear oil and sealed at the factory. The
operator needs only to provide engine lubrication, wheel and cable lubrication.
Supplies Needed:
FLUID FILM ® or comparable lubricant
#2 Lithium Grease
1. There are two grease fittings on the
swivel wheel: one at the top front of the
wheel bracket, and one toward the
center of the wheel (Figure 11). Grease
these two fittings with #2 lithium grease
to keep the wheel spinning freely at least
every 25 hours of operation per the
Maintenance Checklist on page 16.
2. Lubricate the parking brake lever cable
at the operator's end. Clutch lever cable
should be lubricated at both ends (Figures
12 & 13), and the key switch, with
FLUID FILM
®
or similar lubricant.
Operate the levers to work lubricant into
the cables.
WARNING! Before performing any maintenance procedure, stop the
engine, set the parking brake and disconnect the spark plug wire.
Figure 13
Lubricate
Lubricate
Figure 12
Grease Fittings
Lubricate Clutch Cable