Waterpik Technologies pool/spa heater - Manual (Page 29)

LX and LT Pool Heaters
Page 27
SECTION 5.
Parts List
5A. General Information
To order or purchase parts for the Waterpik
Technologies LX or LT pool/spa heater, contact your nearest
Waterpik Technologies dealer or distributor. If they cannot
supply you with what you need, contact the Customer Service
Manager at Waterpik Technologies.
5B. Part Numbers
Key Model ORDER
No. Description No. PART NO:
Water Components
1 Complete Heat Exchanger (Copper) 250,400 R0326303,05
2 Tube Assy.(Cu), w/ Hdwr & Gaskets 250,400 R0326603,05
3 Heat Exchanger Baffles
(Set of ten including end baffles) 250,400 R0334403,05
4 Front Header, w/ Hardware & Gaskets All R0326900
5 Rear Header, w/ Hardware & Gaskets All R0327000
6 By-Pass Assy, w/ Hardware & Gaskets All R0327100
7 Gasket, Bypass Assy All R0336700
8 Spring, Bypass All R0327200
9 Coupling Nut Kit, w/Compression Ring and Gasket,
(Set of two) All R0327300
10 Compression Ring w/ Gasket, I/O Header,
(Set of two) All R0327400
11 Gasket, Header (front or rear) All R0327500
12 Header Drain Plug w/gasket (Set of 3) All R0335900
13* Heat Exch. Hardware Kit & Gaskets All R0327600
Gas Components
14 Burner Tray Weldment 250,400 R0327703,05
15 Burners (Ea.) All L0052300
16 Manifold, Gas 250,400 R0327803,05
17 Nat. Orifice (0-3K ft) (Set of 20) All R0327900
17 Nat. Orifice (3K-6K ft) (Set of 20) All R0328000
17 Nat. Orifice (6K-9K ft) (Set of 20) All R0328100
17 LP Orifice (0-5K ft) (Set of 20) All R0328200
17 LP Orifice (5K-10K ft) (Set of 20) All R0328300
18 Anti-Rotation Bracket All R0331800
19 Gas Valve Nat w/ Street Ell All R0336800
19 Gas Valve LP w/ Street Ell All R0336900
Exhaust System
20 Flue Collector 250,400 R0331703,05
21 Blower Assy. All R0329800
22 Gasket w/ Blower Mounting Hardware All R0329900
23 Flue Vent All R0331500
24 Indoor Vent Collar 250,400 R0331403,05
25 Outdoor Grill All R0328500
26* Vent Hardware Kit All R0331600
Electrical
27 Transformer All R0328700
28* Fuse Assy, In-line All R0337100
29 Blower Pressure Switch All R0302000
30 Temperature Sensor All R0011800
Key Model
ORDER
No. Description No. PART NO:
Electrical (continued)
31 Gasket, Temperature Sensor All E0116400
32 Plastic Sleeve, Temperature Sensor All 10444900
33 Retainer Bracket, Temp. Sensor All 10447300
34 Screw, Retainer Bracket All F0009100
35 Ignition Control All R0328800
36 Pressure Switch Assy All R0334500
37 Pressure Switch, 2 psi All R0013200
38 Siphon Loop All R0334600
39 High Limits Set All R0023200
40 High Limit 135°F All R0022700
41 High Limits 150°F All R0023000
42 Harness, High Limit Switch All R0334700
43 Retainer Plates, High Limit (Set of 2) All R0336500
44 Hot Surface Ignitor All R0337000
45 Exhaust Temp. Limit Switch All R0329400
46* Wire Harnesses Complete All R0329500
47* Wire Harness, Power Transformer All R0330900
48* Wire Harness, Ignition Control All R0331000
49* Wire Harness, Gas Valve All R0331100
50* Wire Harness, Safety Loop All R0331200
51 Wire Harness, 120 Volt Power Plug All R0336200
51 Wire Harness, 240 Volt Power Plug All R0336300
52 Wire Harness, 15 Pin Connector All R0336400
53 Terminal Block for Fireman’s Switch All R0097800
54 Temperature Control W/ Bezel -LX All R0329600
54 Temperature Control W/ Bezel -LT All R0350500
55 Flame Sense Rod All R0334800
56 Fusible Link All R0012200
Jacket Assy.
57 Door w/ Latch 250,400 R0330003,05
58 Door Latch Assembly w/ Handle All R0334900
59 Cover Panel, Raceway 250,400 R0335103,05
60 Panel, Side, Lower (fits left or right) All R0330100
61 Panel, Right Side, Upper All R0330200
62 Cover Panel, Exhaust Switch All R0336600
63 Panel, Left Side, Upper All R0335200
64 Cover Plate, I/O Header Side All R0335300
65 Cover Plate, Return Header Side All R0335400
66 Cover Panel, Left Side All R0335500
67 Rear Panel 250,400 R0330303,05
68 Corner Posts All R0330400
69 Top Assy. 250,400 R0330503,05
70 Cover, Temperature Control All R0330600
71 Combustion Chamber Assy. 250,400 R0330703,05
72 Base Panel 250,400 R0335603,05
73 Igniter Box Assembly All R0335700
74 Bracket, Fusible Link All R0337200
Optional
74* Non Comb. Base 250,400 R0330803,05
75* Touch-up Paint All R0335800
76* Temperature Rise Measurement Kit All R0336000
77 Pressure Relief Valve All R0336100
* PARTS NOT SHOWN ON KEY VIEW
NOTES:
1. When ordering a kit for a model 250 specify as R#####-03,
When ordering a kit for a model 400 specify as R#####-05,
2. All hardware sets contain all pieces necessary for assembly,
including gaskets. Not shown.
3. Gaskets and hardware are included in all kits that involve the
removal of a gasket as part of the procedure to replace a part.