Town One to Six chamber Ranges - Manual (Page 4)

ON position OFF position
MAIN BURNER VALVE
air shut-
ter
(ring
burners
only)
FIGURE 1
FIGURE 2
pilot located in the combustion chamber. Make sure the pilot stays lit.
All units are equipped with fixed orifices which cannot be adjusted for gas flow. Only ring burners have
adjustable air mixers to adjust the air/gas mixture.
Turn right hand burner valve to full “ON” position (see fig.2) and adjust air shutter until proper blue flame is
burning on both inner rings. Repeat operation for left hand valve only if your range is equipped with three
ring burners.
SHUTDOWN: Turn burner valves to "OFF" position (see fig.2) and turn the pilot screw clockwise (see fig.
1) until it cannot be turned further. Repeat this step for each chamber.
OPERATING INSTRUCTIONS
1. INSTALLATION AREA MUST BE FREE AND CLEAR FROM COMBUSTIBLES. Local safety codes should
be complied with in respect to fire avoidance.
Put lit match
to pilot
burner, de-
press & hold
red button
MAIN BURNER VALVE
OFF position ON position
figure 1
figure 2
6. UNITS WITH SAFETY VALVES: LIGHTING AND SHUT DOWN INSTRUCTIONS.
Always follow these lighting and shutdown instructions when operating your unit. A five minute com-
plete shutoff period is required before lighting or relighting pilot. See diagram below.
a) Check that all gas valves on the unit are turned “OFF” (lever handles in horizontal position) before turn-
ing “ON” main gas line. Check for leaks using soapy water or other suitable leak detector. DO NOT
USE OPEN FLAME FOR TESTING.
b) Main burner valve shall be in “OFF” position (figure 2). Place a burning match by the pilot burner in the
combustion chamber of the range. Depress safety control red button on (fig.1 below) and light pilot.
c) The pilot should light. Continue to hold the button for one minute or until the pilot stays lit.
SHUT DOWN: For temporary Shut Down turn all burner valves to "OFF" position. For an extended pe-
riod of time, turn all burner valves "OFF" and also turn off gas supply to the range.
OFF position:
turn clockwise
until screw can-
not be turned
further
ON position
turn counter-
clockwise
PILOT VALVE
4
FOOD SERVICE EQUIPMENT CO., INC. • 72 BEADEL ST • BKLYN • NY 11222