JLG 20VP (3120728) Service Manual - Manual (Page 13)

SECTION 1 - SPECIFICATIONS
3120728 – JLG Lift – 1-1
SECTION 1. SPECIFICATIONS
1.1 CAPACITIES
System Voltage
All VP Models –24 Volt DC (2 - 12 volt DC batteries)
Hydraulic Oil Reservoir
All VP Models – 5 qts. U.S. (4.7 ltr.)
1.2 COMPONENT DATA
Hydraulic Pump/Pump Motor Assembly
Pump Motor - 24 Volt DC motor
Pump Displacement –
10 & 15VP – .098 cu. in./rev. (1.6cc/rev.)
20VP – .049 cu. in./rev. (0.8cc/rev )
Pump Output (Max.) –
10 & 15VP - 1.20 gpm @ 2200 psi
20VP – 0.65 gpm @ 2200 psi
Hydraulic System Pressure Setting –
10 & 15VP - 1000 psi (68.95 bar)
20VP - 2500 psi (172.3 bar)
Rear Wheel Drive Motors
DriveMotors -
24 Volt DC w/perm. magnet
Right angle gear
Maintenance free sealed gear
Brake shaft and drive shaft,Integral to Motor
Parking Brake (must be released for pushing)
Batteries/Battery Charger
Batteries (2) – 12 Volt / 80 Amp Hour –
Deep CycleMarine - RV
Battery Charger –
U.S.A./CAN. –120 Volt A.C. / 60 Hz input
Brazil - 220 Volt A.C./ 60 Hz input
24 volt, 10 amp output -
with 2 amp finish
Reset Circuit Breaker
Automatic Charge Circuit
Plug Interlock Circuit
1.3 PERFORMANCE DATA
Platform Capacity(All Platforms except
Extendible)
10VP –350 lbs. (160 kg)
15VP –350 lbs. (160 kg)
20VP –350 lbs. (160 kg)
Extendible Platform Capacity
ANSI (U.S.) – 300 lbs. (136 kg)
CSA (CAN.) – 250 lbs. (114 kg)
Platform Size
Standard Platform – 26 in. x 26 in.
(66cm) x (66cm)
Machine Height (In Stowed Position)
VP Series - 79 in. (201cm) height
Table 1-1.
Machine GVW and Wheel Loads
VP MODEL CONFIG. GVW (no load)
DRIVE WHEEL
(ea) w/rated load
CASTER
(ea) w/rated load
PSI
(Drive)
PSI
(Caster)
10VP ANSI (U.S.) 930 lb. (422 kg) 424 lb. 216 lb. 76 psi 102 psi
CSA (CAN.) 930 lb. (422 kg) 424 lb. 216 lb. 76 psi 102 psi
15VP ANSI (U.S.) 1,355 lb. (615 kg) 604 lb. 249 lb. 108 psi 117 psi
CSA (CAN.) 1,425 lb. (647 kg) 630 lb. 257 lb. 113 psi 121 psi
20VP ANSI (U.S.) 1,910 lb. (867 kg) 750 lb. 400 lb. 134 psi 188 psi
CSA (CAN.) 2,100 lb. (953 kg) 774 lb. 470 lb. 140 psi 220 psi