Labconco FlaskScrubber Vantage Series Glassware Washers 4540031 - Manual (Page 28)

Chapter 4: Using Your Washer
Product Service 1-800-522-7658 24
24
The Detergent Dispenser in the Door
In addition to the bulk liquid detergent and neutralizing acid rinse dispense
systems, your Glassware Washer is equipped with a detergent dispenser in the
door that contains a main wash cavity and a neutralizing solution port. This
dispenser in the door is active only if the liquid detergent dispensed from the bulk
container is programmed to 0 ml. See “Programming and Starting a Wash
Cycle” instructions later in this section. In addition, the washer door has a
depression where powder detergent may be added for use during the first wash of
the cycle.
The detergent dispenser opens during the second wash cycle, except when the
Plastic cycle is selected, which has only one wash cycle. If your glassware is
heavily soiled, you may want to add powder detergent to the depression in the
washer door. Do not use liquid detergent in the pre-wash cavity in the washer
door. The initial drain and fill cycle flushes the liquid detergent out of the washer
prior to the first wash. Refer to the table below to determine which cavities to fill,
based on the selected wash choice. You may use either the pre-wash cavity
stamped in the washer door or the one on the lid of the detergent cup.
Wash Cycle Fill Pre-wash Cavity Fill Main Cavity
Rinse Only NO NO
Plastic NO YES
All other cycles OPTIONAL YES
Main wash cavity
Neutralizing solution
dispenser cover
Neutralizing
solution port
Neutralizing
solution dial