Empire Products DVC-35T-1 - Manual (Page 20)

Page 20 13119-6-0107
Parts can be ordered only through your service person or dealer. For best results, the service person or dealer should order parts through
the distributor. Parts can be shipped directly to the service person/dealer.
All parts listed in the Parts List have a Part Number. When ordering parts, first obtain the Model Number from the name plate on your
equipment. Then determine the Part Number ( not the Index Number) and the Description of each part from the following appropriate
illustration and list. Be sure to give all this information.
Furnace Model Number
Part Description
Furnace Serial Number Part Number
Type of Gas (Propane or Natural)
Do not order bolts, screws, washers or nuts. They are standard hardware items and can be purchased at any local hardware store.
Shipments contingent upon strikes, fires and all causes beyond our control.
Empire Comfort Systems, Inc. Nine Eighteen Freeburg Ave. Belleville, IL 62222-0529
PLEASE NOTE: When ordering parts, it is very important that part number and description of part coincide.
Index Part
No. Number Description
USE ONLY MANUFACTURER’S REPLACEMENT PARTS. USE OF ANY OTHER PARTS COULD CAUSE INJURY OR DEATH.
1 DV-1213 TOP PLATE
2 R-3165 DOOR CLIP (2 REQUIRED)
3 DV-1204 CASING SIDE - RIGHT
4 DV-1202 CASING BACK
5 DV-1205 CASING SIDE - LEFT
6 DV-1249 AIR DROP
7 DV-1230 TURBULATOR (3 REQUIRED)
8 13213 OUTLET BOX REAR
9 13217 OUTLET BOX COVER
10 R-3161 FAN BLADE
11 R-3166 FAN MOTOR
12 DV-1246 MOTOR MOUNTING BRACKET
13 R-1536 BUSHING (4 REQUIRED)
14 R-1499 RUBBER GROMMET (4 REQUIRED)
15 R-1454 BRASS BUSHING (4 REQUIRED)
16 R-3164 DOOR CLIP (2 REQUIRED)
17 DV-1251 INNER SHIELD - RIGHT (INCLUDES
NO. 22)
18 R-6176 FAN CONTROL SWITCH
19 R-3175 LIMIT SWITCH
20 DV-1255 INNER SHIELD FRONT
21 DV-1253 INNER SHIELD COVER PLATE (2
REQUIRED)
22 DV-1252 INNER SHIELD -LEFT (INCLUDES
NO. 22)
23 13211 EXCHANGER ASSEMBLY
24 R-3162 FILTER
25 R-3163 FILTER RETAINER
26 R-3232 PILOT - NAT (IP ONLY)
26 R-3233 PILOT - LPG (IP ONLY)
27 P-88-52 ORIFICE - NAT (3 REQUIRED)
27 P-88-60 ORIFICE - LPG (3 REQUIRED)
28 DV-1236 MANIFOLD
29 DV-1259 FRONT PANEL
30 P-112 MANIFOLD UNION
31 R-1109 BUSHING
32 R-3170 GAS VALVE - NAT (IP ONLY)
32 R-3171 GAS VALVE - LPG (IP ONLY)
32 R-2148 GAS VALVE - NAT (SPP ONLY)
32 R-5655 GAS VALVE - LPG (SPP ONLY)
33 R-2708 PIEZO IGNITOR (SPP ONLY)
34 DV-781 OBSERVATION HOLE COVER AS-
SEMBLY
35 M-155 GASKET
36 FF-160 PIEZO BRACKET (SPP ONLY)
37 DV-1240 BURNER COMPARTMENT FRONT
38 DV-1265 BURNER COMPARTMENT BODY
Index Part
No. Number Description
39 M-156 GASKET
40 DV-775 SEAL BRACKET (SPP ONLY)
40 DV-691 SEAL BRACKET (IP ONLY)
41 M-148 MANIFOLD GASKET
42 DV-1235 PILOT BRACKET (IP ONLY)
43 R-3031 BURNER (3 REQUIRED)
44 DV-1239 BURNER BRACKET
45 UH-810 TRANSFORMER MOUNTING BRACKET
(SPP ONLY)
45 UH-452 TRANSFORMER MOUNTING BRACKET (IP
ONLY)
46 R-1995 TRANSFORMER (SPP ONLY)
46 R-998 TRANSFORMER (IP ONLY)
47 UH-451 JUNCTION BOX COVER
48 DV-572 JUNCTION BOX
49 R-1410 BUSHING
50 R-690 CORD SET
51 R-1515 BUSHING
52 DV-1215 BOTTOM PLATE
53 R-3034 PILOT - NAT (SPP ONLY)
53 R-3035 PILOT - LPG (SPP ONLY)
54 GWT-021 PILOT BRACKET (SPP ONLY)
55 R-3180 ELECTRODE AND WIRE ASSEMBLY (SPP
ONLY)
56 R-2256 THERMOCOUPLE -18” (SPP ONLY)
57 R-6389 WALL THERMOSTAT - 24 VOLT
58 13057 OUTLET TUBE - INNER ASSEMBLY (IN-
CLUDES 59 & 60)
59 M-177 GASKET - OUTER COLLAR
60 13104 OUTLET TUBE - INNER WELDED ASSEM-
BLY
61 13062 INLET TUBE - INNER ASSEMBLY (IN-
CLUDES 62 & 63)
62 M-178 GASKET - INLET COLLAR
63 13106 INLET TUBE - INNER WELDED ASSEMBLY
64 13064 INLET TUBE - OUTER ASSEMBLY
65 13059 OUTLET TUBE - OUTER ASSEMBLY
66 13053 VENT CAP WELDED ASSEMBLY
NOT SHOWN DV-1261 PILOT TUBING
NOT SHOWN R-1081 PILOT ORIFICE - NAT (SPP ONLY)
NOT SHOWN R-1089 PILOT ORIFICE - LPG (SPP ONLY)
NOT SHOWN R-1233 PILOT ORIFICE - NAT (IP ONLY)
NOT SHOWN R-3265 PILOT ORIFICE - LPG (IP ONLY)
NOT SHOWN R-3172 WIRE HARNESS (SPP ONLY)
NOT SHOWN R-3173 WIRE HARNESS (IP ONLY)
NOT SHOWN R-3236 WIRE (IP ONLY)
NOT SHOWN DV-1264 HARDWARE PACKAGE
HOW TO ORDER REPAIR PARTS
PARTS LIST