Quadra-Fire CB1200M-MBK - Manual (Page 3)

R
December 16, 2011 7014-179D Page 3
CB 1200 Pellet Stove
Section 1: Listing and Code Approvals
A. Appliance Certifications ......................4
B. Mobile Home Approved ......................4
C. Glass Specifications ............................4
D. Electrical Rating ..................................4
E. BTU & Efficiency Specifications ..........4
Section 2: Getting Started
A. Design, Installation & Location
Considerations ....................................5
B. Locating Your Appliance & Chinmey ..6
C. Thermostat Location ...........................6
D. Draft ....................................................6
E. Negative Pressure ..............................6
F. Fire Safety ..........................................7
G. Tools & Supplies Needed ...................7
H. Inspect Appliance & Components.......7
Section 3: Dimensions & Clearances
A. Appliance Dimensions ........................8
B. Clearances to Combustibles ...............9
C. Hearth Requirements..........................10
Section 4: Vent Information
A. Chimney & Exhaust Connection .........11
B. Venting Termination Requirements ....11
C. Equivalent Feet of Pipe .......................12
D. Pipe Selection Chart ............................12
Section 5: Venting Systems
A. Alcove .................................................13
B. Through the Wall .................................14
C. Vertical ................................................15
D. Through the Wall & Vertical - Exterior .15
E. Vertial - Internal ...................................16
E. Masonry ..............................................16
F. Alternate Masonry ...............................16
Section 6: Mobile Home ..................................17
Section 7: Appliance Set-Up
A. Outside Air Kit, Rear & Floor ..............18
B. Top Vent Adapter ...............................19
C. Rear Vent & Rear to Top Vent Adapter .19
D. Brick Set .............................................20
E. Brick Clip ............................................20
F. Log Set Placement ..............................21
G. Grille Assembly ...................................21
H. Logo Installation ..................................21
I. Door Installation ..................................22
J . Thermostat Installation ........................22
Section 8: Operating Instructions
A. Fuel Size & Material ............................23
B. General Operation Information ...........23
C. Before Your First Fire .........................24
D. Starting Your First Fire ........................24
E. Fire Characteristics .............................24
F. Feed Rate Adjustment .......................24
G. Ignition Cycles ....................................25
H. Frequently Asked Questions...............25
Section 9: Troubleshooting ............................26-28
Section 10 : Maintaining & Servicing Appliance
A. Proper Shutdown Procedures .............29
B. Quick Reference Maintenance Chart ..29
C. General Maintenance & Cleaning .......29-32
D. High Ash Fuel Content Maintenance ..33
E. Blower Replacement ...........................33-34
F. Baffle Removal ....................................34
G. Igniter Replacement ............................34
H. Glass Replacement .............................35
Section 11: Reference Material
A. Component Functions & Locations .....36-37
B. Component Locations (Drawings) ......38
C. Exploded Drawings .............................39-40
D. Service Parts & Accessories...............41-45
E. Warranty Policy ...................................46-47
F. Contact Information .............................48
TABLE OF CONTENTS
Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
•
WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Indicates practices which may cause damage to the fireplace or to property.