JELD-WEN JII015 Vinyl Patio Doors without Nailing Fin - Manual (Page 8)

INSTALLATION INSTRUCTIONS
for Vinyl Patio Doors without Nailing Fin (JII015)
8
COMPLETE INSTALLATION - CONTINUED
7
PATIO DOOR ADJUSTMENT
Roller Adjustment
Note!
Adjusting door too high may allow water and air leakage. Adjust
rollers just high enough to clear sill track and still roll smoothly.
1. Builders vinyl doors have an adjustment screw on each lower end of
the operating panel(s), and Premium vinyl doors have access holes on
the face of each lower end of the operating panel(s). Remove small
vinyl plugs from each hole if present.
2. Open operating panel enough to compare with frame jamb.
Note! Builders vinyl roller adjustment screws on the end of the panel
are in close proximity to the attachment screw. Adjust only the lower
screw as shown because loosening the attachment screw will detach
the roller from the operating panel.
3. Using a #2 Phillips
head screwdriver,
turn the adjustment
screw clockwise to
raise the panel, and
counterclockwise to
lower the panel.
4. Premium vinyl doors
may have different
types of rollers. To
identify the roller,
look inside the
adjustment hole.
• If the roller
has a plus (+)
sign, clockwise
rotations will
lower the
panel and
counterclockwise
will raise
the panel.
• If the roller has
a minus (-) sign,
the operations
are reversed.
5. Adjust as needed
until interlocks, grid
patterns and jambs
line up.
6. Test the operating
panel for proper
operation.
7. Re-apply the small
vinyl caps over the
roller adjustment
screw holes
if applicable.
Lock Adjustment
Note!
If the strike plate
was not previously
installed, line up the
screw holes with
the dimples in the
operating panel side
jamb and drive screws
through the two
slotted screw holes.
If the lock does not
properly engage the
strike plate:
• Loosen the strike
plate screws and
move up or down
until the latch
engages properly.
If the door does
not lock or is loose
when locked:
• Turn the latch
adjustment screw(s) in
1/2 turn increments:
clockwise to loosen
or counterclockwise
to tighten. Premium
vinyl doors have a
double latch and two
adjustment screws.
Premium Patio Door
Attachment
screw
Adjustment
screw
Lower panel
Raise panel
Builders Roller
Builders Patio Door
Builders Patio Door
Lock hook
adjustment
screw
Strike plate
Premium Patio Door
Lock hook
adjustment
screw
Lock hook
adjustment
screw