JLG G10-43A (0160005444 & After) Operator Manual User Manual
Page 39
Section 2 - Pre-Operation and Inspection
2-15
31200150
5. Mirrors - Clean and undamaged.
6. Cab and Electrical -
• General appearance; no visible damage.
• Frame level indicator and window glass undamaged and clean.
• Gauges, switches, joysticks, foot controls and horn operational.
• Emergency escape hammer in place (enclosed cab only).
• Check seat belt for damage, replace belt if frayed or cut webbing, damaged
buckles or loose mounting hardware.
7. Air Cleaner (Before S/N 0160040675 excluding 0160040468 & 0160040672) -
Air cleaner element condition indicator, check for clogged condition. Replace
element as required.
8. Main Control Valve - See inspection note.
9. Wheel/Tire Assembly - Properly inflated and secured; no loose or missing lug
nuts. Inspect for worn tread, cuts, tears or other discrepancies.
10. Stabilizer Cylinder (if equipped) - Pins secure; hydraulic hoses undamaged, not
leaking.
11. Rear Axle - Steer cylinders undamaged, not leaking; pivot pins secure;
hydraulic hoses undamaged, not leaking.
12. Wheel/Tire Assembly - Properly inflated and secured; no loose or missing lug
nuts. Inspect for worn tread, cuts, tears or other discrepancies.
13. Engine Compartment -
• Air Cleaner (S/N 0160040675 & After including 0160040468 & 0160040672) -
Air cleaner element condition indicator, check for clogged condition. Replace
element as required.
• Drive belts, check condition and replace as required.
• Engine mounts - See inspection note.
• Battery cables tight, no visible damage or corrosion.
• Engine cover properly secured.
14. Outrigger Control Valve (G10-43A) - See inspection note.
15. Wheel/Tire Assembly - Properly inflated and secured; no loose or missing lug
nuts. Inspect for worn tread, cuts, tears or other discrepancies.
16. Frame Level Cylinder - Pins secure; hydraulic hoses undamaged, not leaking.
17. Right Outrigger (G10-43A) - Pins secure; hydraulic hoses and cylinder
undamaged, not leaking.
18. Attachment - Properly installed, see See “Attachment Installation” on