Landoll SL/SLB/SLP/SLPB/SLPB TURFMAKER III - Manual (Page 9)

INTRODUCTION AND SAFETY INFORMATION
1-5
Figure 1-3: Safety Signs (1 of 2)
CAUTION
BE SURE TO ENGAGE
PARKING PIN ON LEFT END OF
FRAME BEFORE UNHITCHING
TRACTOR. OTHERWISE
FRAME WILL TIP BACKWARDS
ABOUT FRONT AXLE
9J302
1
WARNING
DO NOT GO NEAR LEAKS
High pressure oil easily punctures
skin causing serious injury,
gangrene or death.
If injured, seek emergency medical
help. Immediate surgery is
required to remove oil.
Do not use fingers or skin to
check for leaks.
Lower load or relieve hydraulic
pressure before loosening fittings.
PLANTING RATES FOR FRONT SEED BOX
1. Rates are for 11 tooth driver. Double these values for 22 tooth driver.
2. Rates are intended as a guide only. Variation in size and cleanliness will affect rates.
Check acreage and pounds of seed used for best results. PLANTING RATES FOR FRONT SEED BOX
INDICATOR SETTING 1A 2A 3A 4A 5A 6A 7A 8A 1A 2A 3A 4A 5A 6A 7A 8A
KENTUCKY BLUEGRASS 4 8 16 29 39 49 64 74 0.10 0.20 0.37 0.67 0.90 1.12 1.47 1.69
TALL FESCUE 4 8 18 30 48 58 72 88 0.09 0.18 0.41 0.69 1.10 1.33 1.65 2.02
ALFALFA 6 14 30 48 67 90 110 129 0.13 0.33 0.70 1.10 1.54 2.06 2.53 2.97
BAHIA 4 13 29 47 60 71 90 102 0.10 0.30 0.67 1.07 1.37 1.63 2.06 2.33
BARLEY 1 14 33 51 70 86 103 122 0.03 0.33 0.76 1.16 1.60 1.97 2.37 2.80
BENT 3 7 14 26 42 52 61 77 0.07 0.17 0.33 0.60 0.97 1.20 1.40 1.77
BERMUDA 6 17 29 48 70 99 118 145 0.13 0.40 0.67 1.10 1.60 2.27 2.70 3.34
BIRDSFOOT TREFOIL 6 16 30 52 71 93 118 138 0.13 0.37 0.70 1.20 1.63 2.13 2.70 3.17
BUFFALO GRASS - 1 7 14 20 25 28 35 -- 0.03 0.17 0.33 0.47 0.57 0.64 0.80
CANOLA 6 17 33 51 71 87 103 115 0.13 0.40 0.76 1.16 1.63 2.00 2.37 2.63
CENTIPEDE 6 14 28 52 83 105 129 144 0.13 0.33 0.64 1.20 1.90 2.40 2.97 3.30
CLOVER, ALSIKE 6 14 33 58 81 105 129 145 0.13 0.33 0.76 1.33 1.87 2.40 2.97 3.34
CLOVER, RED 9 19 32 45 57 78 86 96 0.20 0.43 0.73 1.03 1.30 1.66 1.97 2.20
CREEPING RED FESCUE 1 4 12 23 30 38 45 48 0.03 0.10 0.26 0.53 0.70 0.87 1.03 1.10
LOVE GRASS 9 20 47 73 97 118 142 166 0.20 0.47 1.07 1.66 2.23 2.70 3.27 3.80
LESPEDEZA (HULLED) 7 20 42 68 103 123 145 169 0.17 0.47 0.97 1.57 2.37 2.83 3.34 3.87
LESPEDEZA (UNHULLED) 3 10 19 35 48 58 70 83 0.07 0.23 0.43 0.80 1.10 1.33 1.60 1.90
MILLET 4 9 29 48 65 81 96 112 0.10 0.20 0.67 1.10 1.50 1.87 2.20 2.56
MILO 12 28 44 61 83 100 112 134 0.26 0.64 1.00 1.40 1.90 2.30 2.56 3.07
NEEDLE GRASS 1 7 22 38 55 71 91 103 0.03 0.17 0.50 0.87 1.27 1.63 2.10 2.37
OATS 7 14 25 33 48 57 64 74 0.17 0.33 0.57 0.76 1.10 1.30 1.47 1.70
ORCHARD GRASS 1 3 6 13 22 25 29 32 0.03 0.07 0.13 0.30 0.50 0.57 0.67 0.73
RYE GRASS 3 9 20 32 44 55 65 75 0.07 0.20 0.47 0.73 1.00 1.27 1.50 1.73
SUDAN 3 16 35 55 75 99 122 142 0.07 0.37 0.80 1.27 1.73 2.27 2.80 3.27
SWITCH GRASS 4 13 33 60 83 100 123 149 0.10 0.30 0.76 1.37 1.90 2.30 2.83 3.43
TIMOTHY 4 12 32 52 70 91 103 121 0.10 0.26 0.73 1.20 1.60 2.10 2.37 2.77
VETCH 3 17 36 54 73 90 109 125 0.07 0.40 0.83 1.23 1.66 2.06 2.50 2.87
WESTERN WHEAT GRASS - 3 10 20 29 38 42 50 -- 0.07 0.23 0.47 0.67 0.87 0.97 1.16
WINTER WHEAT 13 26 45 64 81 100 116 131 0.03 0.60 1.03 1.47 1.87 2.30 2.67 3.00
Seed Rate Calibration
•Seed rate charts are located inside the seed box covers of both the front and rear seed boxes.
They should be used as general guides only. Because of seed variation, a more accurate rate
can be found by calibrating the seeder as shown in steps 1-6.
•The provided charts were determined by laboratory tests on various samples. To fnd rates for
specifc seed lots or to calibrate for unlisted seeds, proceed as shown on the seed charts.
Calibration of Front Seed Box
Front Seed Box May be calibrated for unlisted seed as follows:
1. Raise Machine and Lock in transport position.
2. Disengage clutch (electrical power is required to disengage).
3. Close Meters of rear seed box if box contains seed.
4. Place a tarp under machine to collect seed.
5. Turn the 11/16 Hex on transmission clockwise as follows:
•118 revolutions for 8-foot seeder •92 revolutions for 10-foot seeder •78 revolutions for 12-foot seeder
6. Weigh seed for approximate planting rate in pounds/acre.
Seed rate will be doubled if 22 tooth sprocket is used.
11/16 HEX
11 Tooth Driver
(Using the 22 Tooth sprocket
doubles the seed rates shown.)
6K693A
10
OPEN
CLOSED
9
K
7
8
8
1. 4K706 - Hydraulic Leak Warning
2. 8J309 - Caution Decal
3. 9J302 - Parking Pin Caution
4. 2K123 - Moving Parts Warning
8. 9J301 - Parking Pin Decal
9. 5K395 - Rising Drawbar Caution
5. 528938 - Orange Stripe
6. 528934 - Amber Reflective
7. 528933 - Red Reflective
CAUTION
5K395
• DRAWBAR MAY RISE RAPIDLY
WHEN UNHITCHED.
• SL2 SEEDERS WITH REAR BOXES
ARE DRA
WBAR-LIGHT WHEN ROLLERS
ARE LOWERED TO THE GROUND.
• SEE OPERATOR’S MANUAL FOR
DETAILED INSTRUCTIONS.
!
3
11
PARKING PIN
9J
30
1
8
7
5
6
4
WARNING
MOVING PART HAZARD
TO PREVENT SERIOUS INJURY FROM
MOVING PARTS:
KEEP COVERS CLOSED DURING OPERATION.
DO NOT ALLOW ANYONE TO RIDE OR CLIMB
MACHINE DURING OPERATION.
KEEP OBSERVERS AWAY.
2K123
2
CAUTION
MOVING MACHINES CAN CAUSE INJURY. KEEP AWAY!
1. KEEP AWAY FROM MOVING TRACTORS OR IMPLEMENTS.
KEEP OTHERS AWAY.
2. DO NOT RIDE OR ALLOW OTHERS TO RIDE ON TRACTOR
OR IMPLEMENT.
3. BLOCK IMPLEMENT TO PREVENT MOVEMENT WHEN
UNHITCHED FROM TRACTOR.
4. KEEP ALL GUARDS AND SHIELDS IN PLACE WHILE
MACHINE OR PARTS ARE IN MOTION.
8J309
9
OTHER DECALS
10. 6K693- (front) Seed Chart
6K694 - (rear) Seed Chart
11. 9K788 - Cover Handle Decal
12. 4K039 - BRILLION
4K037 - BRILLION
13. 4K338 - TURFMAKER
14. 6K690 - SL308
6K691 - SL310
6K692 - SL312
TurfmakerSL312
12
14 13