Soniclean UW3000 - Manual (Page 5)

iii) PC Connection: take the PC cable provided and push the black plug into
the MRS socket provided on the Washer. Plug the other end (RJ45) into
the appropriate outlet on the PC.
iv) Temperature Sensor: Push the ambient temperature sensor probe into
the temperature sensor socket found on the right side of the machine.
2.4 Printer (optional)
i)Plug the machine into mains supply and turn on at the switch.
ii)Plug the printer cable into the machine and the printer.
iii)Press the feed button to progress the paper.
2.5. Detergent Bottle:
i)
Open door on front of wash unit.
ii) Place filtered end of detergent hose into container.
iii) Place detergent bottle into compartment
iv) Ensure there is sufficient detergent in bottle at all times.
v) Check level of detergent regularly.
Caution: (MRS units only)
Only use designated cables for accessing data from the Washer.
The cable marked ‘PC’ should be used with a laptop computer.
The cable marked ‘LAN’ should be used for connection to a LAN
wall outlet.
3. Installation Requirements
IMPORTANT NOTE:
The customer shall ensure the following requirements are met prior to
installation. This is essential for the machine to perform at optimum
level and to fulfil Australian Standards.
If the customer fails to provide this information, Soniclean will provide
the information for a fee.
3.1. Environmental:
i) Use hot and cold water .
ii) A tap or inlet must be dedicated to the Washer.
iii) Water Quality for cleaning as per AS/NZS 4187:2003 shall be used. Water
hardness will determine the type of detergent to be used. It will also
determine the amount of detergent to be used in the cleaner.
3.2. Plumbing:
i) Maximum water pressure 150 psi, minimum water pressure 30 psi.
ii) Flow rate 10 litres/minute (minimum) to 20 litres/minute (maximum).
iii) This is a High Hazard application and the inlet mains supply shall be fitted
with an approved Reduced Pressure Zone Device and a line filter. (Please
check with your local Water Authority for the correct installation information
for your area.)
UW-3000 Washer Operating Manual Page 5 of 24
© Soniclean Pty Ltd Version 2.0 April 2009