Generac DUARDIAN 04077-2 - Manual (Page 4)

SAFETY RULES
Important Safety Instructions
Guardian Air-cooled 6 kW, 8 kW and 10 kW Generators
SAVE THESE INSTRUCTIONS
-
The manufacturer suggests that these rules for safe
.
A
operation be copied and posted near the unit’s installation site. Safety should be stressed
Vk
to all operators and potential operators of this equipment.
WARNING:
The engine exhaust from this product
contains chemicals known to the state
of California to cause cancer, birth
WARNING:
I This product contains or emits chemicals
I
known to the state of California to cause
I
cancer, birth defects or other reproductive harm.
Study these SAFETY RULES carefully before
installing, operating or servicing this equipment.
Become familiar with this
Owners Manual
and with
the unit. The generator can operate safely, efficient­
ly and reliably only if it is properly installed, operat­
ed and maintained. Many accidents are caused by
failing to follow simple and fundamental rules
or precautions.
Generac cannot possibly anticipate eveiy possi­
ble circumstance that might involve a hazard. The
warnings in this manual, and on tags and decals
affixed to the unit are, therefore, not all-inclusive. If
you use a procedure, work method or operating
technique Generac does not specifically recom­
mend, you must satisfy yourself that it is safe for
you and others. You also must make sure the pro­
cedure, work method or operating technique that
you clioosc does not render the generator unsafe.
DANGER
A
Despite the safe design of this generator,
operating this equipment imprudently, neglecting
its maintenance or being careless can cause
possible injury or death. Permit only responsible
and capable persons to operate or maintain this
equipment.
Potentially lethal voltages are generated by
these machines. Ensure all steps are taken to
render the machine safe before attempting to
work on the generator.
Parts of the generator are rotating and/or hot
during operation. Exercise care near running
generators.
^ GENERAL HAZARDS A
For .safety reasons, Generac recommends
that the installation, initial start-up and mainte­
nance of this equipment is carried out by a
Generac/Guardian Authorized Dealer.
The engine exhaust fumes contain carbon
monoxide, which can be DEADLY. This danger­
ous gas, if breathed in sufficient concentrations,
can cause unconsciousness or even death. This
exhaust system must be installed properly, in
strict compliance with applicable codes and stan­
dards. Following installation, you must do noth­
ing that might render the system unsafe or in
noncompliance wi.th such codes and standards.
Keep hands, feet, clothing, etc., away from drive
belts, fans, and other moving or hot parts. Never
remove any drive belt or fan guard while the unit
is operating.
Adequate, unobstructed flow of cooling and ven­
tilating air is critical to correct generator opera­
tion. Do not alter the installation or permit even
partial blockage of ventilation provisions, as this
can seriously affect safe operation of the genera­
tor. The generator MUST be installed outdoors.
When working on this equipment, remain alert at
all times. Never work on the equipment when you
are physically or mentally fatigued.
Inspect the generator regularly, and contact your
nearest Generac/Guardian Authorized Dealer for
parts needing repair or replacement.
Before perfoiming any maintenance on the gen­
erator, disconnect its batteiy cables to prevent
accidental start up. Disconnect the cable from
the battery post indicated by a NEGATIVE, NEG
or H first. Reconnect that cable last.
Never use the generator or any of its parts as a
step. Stepping on the unit can stress and break
parts, and may result in dangerous operating
conditions from leaking exhaust gases, fuel leak­
age, oil leakage, etc.
Generac* Power Systems, Inc.