Generac Power Systems 009600-4 - Manual (Page 5)

Safety Rules
SAFETY RULES
PRIMEPACT 66C and 66LP Recreational Vehicle Generators
A ELECTRICAL HAZARDS
A
A FIRE HAZARDS A
• The generator covered by this manual produces
dangerous electrical voltages and can cause fatal
electrical shock. Avoid contact with bare wires, ter­
minals, connections, etc., while the unit is running.
Ensure all appropriate covers, guards and barriers
are in place before operating the generator. If you
must work around an operating unit, stand on an
insulated, dry surface to reduce shock hazard.
• Do not handle any kind of electrical device while
standing in water, while barefoot, or while hands
or
feet are wet. DANGEROUS ELECTRICAL
SHOCK MAY RESULT.
• During installation onto the vehicle, have the gen­
erator properly grounded (bonded) either by solid
mounting to the vehicle frame or chassis, or by
means of an approved bonding conductor. DO
NOT
disconnect the bonding conductor, if so
equipped. DO NOT reconnect the bonding conduc­
tor to any generator part that might be removed or
disassembled
during routine maintenance. If the
grounding conductor must be replaced, use only a
flexible conductor that is of No. 8 American Wire
Gauge (AWG) copper wire minimum.
• In case of accident caused by electric shock, imme­
diately shut down the source of electrical power. If
this is not possible, attempt to free the victim from
the live conductor. AVOID DIRECT CONTACT
WITH THE VICTIM. Use a nonconducting imple­
ment, such as a rope or board, to free the victim
from the live conductor. If the victim is uncon­
scious, apply first aid and get immediate medical
help.
• Never wear jewelry when working on this equip­
ment. Jewelry can conduct electricity resulting in
electric shock, or may get caught in moving com­
ponents causing injury.
For fire safety, the generator must be installed and
maintained properly. Installation always must
comply with applicable codes, standards, laws and
regulations.
Adhere strictly to local, state and
national electrical and building codes. Comply
with regulations the Occupational iSafety and
Health Administration (OSHA) has established.
Also, ensure that the generator is installed in
accordance
with the manufacturer’s instructions
and recommendations. Following proper installa­
tion, do nothing that might alter a safe installation
and render the unit in noncompliance with tlie
aforementioned codes, standards, laws and regu­
lations.
Keep a fire extinguisher in the vehicle at all times.
Extinguishers rated ’ABC” by the National Fire
Protection Association are appropriate for use on
the
recreational vehicle generator electrical sys­
tem. Keep the extinguisher properly charged and
be familiar with its use. If you have any question
pertaining to fire extinguishers, consult your local
fire department.
A
EXPLOSION HAZARDS
A
Do not smoke around the generator. Wipe up any
fuel or oil spills immediately. Ensure that no com­
bustible materials are left in the generator com­
partment, or on or near the generator, as FIRE or
EXPLOSION may result. Keep the area surround­
ing the generator clean and free from debris.
Gasoline is extremely FLAMMABLE and its vapors
are EXPLOSIVE. Do not permit smoking, open
flame, sparks or any source of heat in the vicinity
while handling gasoline. Comply with all laws gov­
erning the storage and handling of gasoline.
This generator may use liquid propane (LP) gas as
a fuel, LP gas is highly EXPLOSIVE. The gas is
heavier than air and tends to settle in low areas
where even the slightest spark can ignite the gas
and cause an explosion.
Generac® Power Systems, Inc.