TOYOTA 5603 - Manual (Page 32)

32 ‘05-‘09 Tacoma (W/O Hitch) - 3” Kit 5603
Miscellaneous
1. Apply kit label (warning) to dashboard in plain sight
of all vehicle occupants.
2. Check all fasteners to ensure they are tight.
3. Ensure all wires, hoses, cables, etc. are properly
connected and there is ample slack.
4. Fill and check power steering reservoir with fresh
power steering fluid. Start engine and turn wheel
several times in either direction. Shut off engine and
recheck power steering reservoir. Add fluid, if neces-
sary.
Dynamic Vehicle Check
1. Check steering in both directions to ensure that
there is no bind. Check operation of clutch, brake
system, and parking brake. Check operation of
transmission and transfer case. Ensure there is full
engagement in all gears and 4WD ranges. Check
battery connections and electrical component oper-
ations. Test-drive vehicle..
WARNING
Retorque all fasteners after 500 miles and after off road
use. All body lift components should be visually
inspected and fasteners retorqued during routine vehi-
cle servicing.
CAUTION
Performance Automotive Group does not recommend
any particular wheel and tire combinations for use with
its body lifts and cannot assume responsibility for the
customer’s choice of wheels and tires. Refer to your
owner's manual for recommended tire sizes and warn-
ings related to the use of oversized tires. Larger wheel
and tire combinations increase stress and wear on
steering and suspension components, which leads to
increased maintenance and higher risk for component
failure. Larger wheel and tire combinations also alter
speedometer calibration, braking effectiveness, center
of gravity, and handling characteristics. Consult an
experienced local off road shop to find what wheel and
tire combinations work best with your vehicle.
Accessories
The following accessories are also available:
Kit# 6337 - Gap Guards