Wayne-Dalton TORQUEMASTER 46 - Manual (Page 2)

2
Please Do Not Return This Product To The Store. Contact your local Wayne-Dalton dealer. To find your local Wayne-Dalton dealer, refer to your
local yellow pages/business listings or go to the Find a Dealer section online at www.wayne-dalton.com
Table of Contents
Important Safety Instructions ............................................ 2
Package Contents ..........................................................3-4
Door Section Identification ................................................ 4
Tools Required .................................................................. 5
Preparing The Opening ..................................................... 6
Installation ..................................................................7-31
Optional Installations .................................................32-36
Side Lock ....................................................... 32
Alternative Step Plate ..................................... 33
Pull Rope ........................................................ 33
Trolley Operator .............................................. 34
Maintenance ................................................................... 35
Cleaning ......................................................... 35
Painting Instructions ....................................... 35
Warranty ......................................................................... 36
Dealer Locator Information.............................................. 36
Definition of key words used in this manual:
INDICATES A POTENTIALLy hAzARDOuS
SITuATION WhICh, If NOT AVOIDED, COuLD
RESuLT IN SEVERE OR fATAL INjuRy.
CAUTION: PROPERTy DAMAGE OR INjuRy CAN RESuLT
fROM fAILuRE TO fOLLOW INSTRuCTIONS.
IMPORTANT: REquIRED STEP fOR SAfE AND PROPER
DOOR OPERATION.
NOTE: Information assuring proper installation of the door.
TO AvOID POSSIblE INjURy, READ ThESE
INSTRUCTIONS CAREFUlly bEFORE
ATTEMPTINg INSTAllATION. IF IN qUESTION
AbOUT ANy OF ThE PROCEDURES, DO NOT
PERFORM ThE wORk. INSTEAD, hAvE A
TRAINED DOOR SySTEMS TEChNICIAN DO
ThE INSTAllATION OR REPAIRS.
1. READ AND FOllOw All INSTAllATION INSTRUCTIONS.
2. Wear protective gloves during installation to avoid possible
cuts from sharp metal edges.
3. It is always recommended to wear eye protection when using
tools, otherwise severe or fatal eye injury could result.
4. Avoid installing your new door on windy days. Door could
fall during the installation causing severe or fatal injury.
5. Doors 12’-0” wide and wider should be installed by two
persons, to avoid possible injury.
6. Operate door ONLy when it is properly adjusted and free from
obstructions.
7. If a door becomes hard to operate, inoperative or is damaged,
immediately have necessary adjustments and/or repairs
made by a trained door system technician using proper tools
and instructions.
8. DO NOT stand or walk under a moving door, or permit
anybody to stand or walk under an electrically operated door.
9. DO NOT place fingers or hands into open section joints when
closing a door. use lift handles/gripping points when operating
door manually.
10. DO NOT permit children to operate garage door or door
controls. Severe or fatal injury could result, should the child
become entrapped between the door and the floor.
11. Due to constant extreme spring tension, DO NOT attempt any
adjustment, repair or alteration to any part of the door,
especially to springs, spring brackets, bottom corner brackets,
red colored fasteners, cables or supports. To avoid possible
severe or fatal injury, have any such work performed
by a trained door systems technician using proper tools and
instructions.
12. On electrically operated doors, pull down ropes must be
removed and locks must be removed or made inoperative in
the open (unlocked) position.
13. Top section of door may need to be reinforced when attaching
an electric opener. Check door and/or opener manufacturer’s
instructions.
14. VISuALLy inspect door and hardware monthly for worn and/or
broken parts. Check to ensure door operates freely.
15. Test electric opener’s safety features monthly, following
opener manufacturer’s instructions.
16. NEVER hang tools, bicycles, hoses, clothing or anything else
from horizontal tracks. Track systems are not intended or
designed to support extra weight.
After installation is complete, fasten this manual
near garage door.
wARNINg
wARNINg