Iris Sample Processing StatSpin® ThermoBrite Denaturation and Hybridization - Manual (Page 17)

13
Section
5
Maintenance
Overview
Iris Sample Processing recommends that instrument operators perform periodic inspections and
preventative maintenance on all Iris Sample Processing instruments. Contact Iris Sample
Processing
’s customer service department or distributor if, at any time, the instrument is not
functioning properly.
CAUTION - Unplug the ThermoBrite from the wall outlet before performing
maintenance.
WARNING - Do not expose ThermoBrite to strong or concentrated acids, bases,
esters, aromatic or halogenated hydrocarbons, ketones or strong oxidizing agents.
Cleaning
The ThermoBrite is supplied with a removable slide-locating bar. To remove, pull locator back
releasing the top from its holder (the locator is spring loaded to hold it in position). Lift slide-
locator up and remove from spring holder at bottom. Set on bench top. Clean the outside
surfaces and switch overlay panel with a water-dampened cloth and mild detergent. Clean the inner
surface with a mild detergent, and if necessary, a disinfectant, wiping surfaces with a
dampened
cloth using 70% alcohol or 10% bleach solution. DO NOT use harsh abrasives (i.e. Scotch Brite),
this will scratch the heating surface.
The fan filter, located on the underside of the ThermoBrite should be rinsed with water and air-dried
as needed.
Service
There are no user-serviceable parts. Refer all service to qualified service personnel. Reference the
Iris Sample Processing Warranty for further instruction. Be sure to complete and return the warranty
card as directed.
Decontamination before returning for service
Any instrument or accessory containing accumulated blood and/or other biological or chemical
deposits must be cleaned prior to shipment to the manufacturer/dealer for service. This
decontamination is required by Federal Law (Title 48 and 49 of the Federal Regulations) and in
accordance with the Environmental Protection Agency’s Regulations for Biohazard Waste
Management. Iris Sample Processing personnel cannot perform this decontamination.