Emerson NGA 2000 TO2 - Manual (Page 76)

MATERIAL SAFETY DATA SHEET 748377-B
NOTICE: WHILE ROSEMOUNT ANALYTICAL BELIEVES THE INFORMATION CONTAINED HEREIN IS VALID
AND ACCURATE, ROSEMOUNT ANALYTICAL MAKES NO WARRANTY OR REPRESENTATION AS TO ITS
VALIDITY, ACCURACY, OR CURRENCY. ROSEMOUNT ANALYTICAL SHALL NOT BE LIABLE OR OTHER-
WISE RESPONSIBLE IN ANY WAY FOR USE OF EITHER THIS INFORMATION OR THE MATERIAL TO
WHICH IT APPLIES. DISPOSAL OF HAZARDOUS MATERIAL MAY BE SUBJECT TO FEDERAL, STATE, OR
LOCAL LAWS AND/OR REGULATIONS.
Sheet 2 of 2 September 2000
SECTION VI – HEALTH HAZARD DATA
Threshold limit value NA
Routes of entry Inhalation, eyes, skin, ingestion
Effects of overexposure
Corrosive to tissue. Inhalation of mist may cause respiratory tract
damage,
Emergency & first aid procedures
Eyes - Corrosive, immediately flush with water for at least 15 minutes.
Call a physician.
Skin - Corrosive, remove contaminated clothing. Wash with soap or
mild detergent and large amounts of water at least 15 minutes. Call a
physician.
Inhalation - Corrosive, remove to fresh air immediately. Get medical
attention immediately.
Ingestion - Corrosive/toxic, give water or milk immediately and allow
vomiting to occur, keeping head below hips to prevent aspiration. Get
medical attention immediately.
SECTION VII – SPILL OR LEAK PROCEDURE
Steps to be taken in case material is
released or spilled Neutralize with dilute acid, take up with sand or other absorbent
material and place in container for disposal.
Waste disposal method
Disposal must be in accordance with standards applicable to
generators of hazardous waste, 40CFR262. EPA Hazardous
waste number D002.
SECTION VIII – SPECIAL PROTECTION INFORMATION
Respiratory protection NA
Ventilation mechanical (general)
Protective gloves rubber gloves
Eye protection splash proof or dust-resistant safety goggles with face shield
Other protective equipment
appropriate protective clothing and equipment to prevent
possibility of skin contact. Eye wash fountain, safety shower.
SECTION IX – SPECIAL PRECAUTIONS
Precautions to be taken in handling
and storing
Store away from incompatible substances.
Other precautions none
SECTION X – TRANSPORTATION
DOT Hazard Classification 49CFR172.101: Potassium Hydroxide Solution, Class 8, UN1814, Packing Group
II
♦ Exceptions: When transported by Air 49CFR173.154 (b) (1) + (2)
♦ Exceptions: By Motor Vehicle or Rail Car 49CFR173.154 (d) (1)
IATA Hazard Classification 4.2: Potassium Hydroxide Solution, Class 8, UN1814, Packing Group II
Exceptions: 2.8 (Ltd. Qty.)