Napoleon Fireplaces Castlemore GDS26N - Manual (Page 2)

2
W415-0607 / A / 01.18.08
• Do not burn wood or other materials in this stove.
• Adults and especially children should be alerted to the hazards of high surface temperatures and should stay away to avoid burns or
clothing ignition. Supervise young children when they are in the same room as the stove.
• Clothing or other fl ammable material should not be placed on or near the stove.
• Due to high temperatures, the stove should be located out of traffi c and away from furniture and draperies.
• Ensure you have incorporated adequate safety measure to protect infants/toddlers from touching hot surfaces.
• Even after the stove is out, the glass and/or screen will remain hot for an extended period of time.
• Check with your local hearth specialty dealer for safety screens and hearth guards to protect children from hot surfaces. These
screens and guards must be fastened to the fl oor.
• Any safety screen or guard removed for servicing must be replaced prior to operating the stove.
• It is imperative that the control compartments, burners and circulating blower and its passageway in the stove and venting system are
kept clean. The stove and its venting system should be inspected before use and at least annually by a qualifi ed service person. More
frequent cleaning may be required due to excessive lint from carpeting, bedding material, etc. The stove area must be kept clear and
free from combustible materials, gasoline and other fl ammable vapours and liquids.
• Under no circumstances should this stove be modifi ed.
• This stove must not be connected to a chimney fl ue pipe serving a separate solid fuel burning appliance.
• Do not use this stove if any part has been under water. Immediately call a qualifi ed service technician to inspect the stove and to
replace any part of the control system and any gas control which has been under water.
• Do not operate the stove with the glass door removed, cracked or broken. Replacement of the glass should be done by a licensed or
qualifi ed service person.
• Do not strike or slam shut the stove glass door.
• This stove uses and requires a fast acting thermocouple. Replace only with a fast acting thermocouple supplied by Wolf Steel Ltd.
• Pressure relief doors must be kept closed while the stove is operating to prevent exhaust fumes containing carbon monoxide, from
entering into the home. Temperatures of the exhaust escaping through these openings can also cause the surrounding combustible
materials to overheat and catch fi re.
• Only doors / optional fronts certifi ed with the unit are to be installed on the appliance.
NOTE: Changes, other than editorial, are denoted by a vertical line in the margin.
TABLE of CONTENTS
RETAIN THIS MANUAL FOR FUTURE REFERENCE
PG 3-5 INTRODUCTION
Warranty
General Instructions
General Information
Care of Glass and Plated Parts
Dimensions
5-15 VENTING
Venting Lengths and Air Terminal Locations
Vent Installations
Typical Vent Installations
Special Vent Installations
Minimum Air Terminal Location Clearances
Venting Application Flow Chart
Venting Specifi cations
Vertical Through Existing Chimney
Rear Exit Conversion
16-20 INSTALLATION
Wall and Ceiling Protection
Horizontal Installation
Vertical Installation
Stove Vent Connection
Horizontal Venting Installation
Vertical Venting Installation
Mobile Home Installation
Gas Installation
Minimum Clearances to Combustibles
Minimum Mantel, Shelf or Ceiling Clearances
21 BLOWER INSTALLATION
21 NIGHT LIGHT TM REPLACEMENT
22-23 FINISHING
Glass Door Installation and Removal
Logo Placement
Glass Door Replacement
Switch Functions
Log Placement
24 WIRING DIAGRAM
25 OPERATION / MAINTENANCE
Operating Instructions
Maintenance
26 ADJUSTMENTS
Pilot Injector and Orifi ce Replacement
Flame Adjustment and Characteristics
Venturi Adjustment
27-28 REPLACEMENTS
Ordering Replacement Parts
Replacement Parts
Terminal Kits
Accessories
29-30 TROUBLE SHOOTING GUIDE
31 SERVICE
HISTORY
32 NOTES
!
WARNING