Poweramp VS SERIES HYDRAULIC - Manual (Page 21)

19 4111-0008 — Sept 2012
OPERATION
Operating Instructions
The dock leveler operating instructions are
divided into the two methods of loading and
unloading:
• For ramp loading and unloading, see Ramp
Loading/Unloading Instructions on page 20.
• For end loading and unloading, see End
Loading/Unloading Instructions on page 21.
Stay clear of dock leveler when freight carrier is
entering or leaving dock area.
DO NOT move or use the dock leveler if anyone is
under or in front of leveler.
Keep hands and feet clear of pinch points. Avoid
putting any part of your body near moving parts.
Failure to follow these instructions may result in
severe personal injury or death.
Only trained personnel should operate the dock
leveler.
DO NOT use a broken or damaged dock leveler.
Make sure proper service and maintenance
procedures have been performed on leveler before
using.
Truck/trailer wheels must be chocked unless the
truck restraint is used. Never remove the wheel
chocks until loading/unloading is finished and truck
driver has been given permission to leave.
Make sure platform lip rests on the truck/trailer bed
with at least 4 in. (102 mm) of overlap.
Maintain a safe distance from side edges of leveler
during the loading/unloading process.
Failure to follow these instructions may result in
serious personal injury or death.
1.50"
3.
00"
Control Box Size: Overlay
Decal Size: 1.5 x 3
File Name: 1751-0736
DANGER
Hazardous Voltage
Will Cause Severe
Injury or Death
Arc Flash and
Shock Hazard
PPE (Personal Protection
Equipment) Required
De-energize equipment before
working on or inside. Do not
open cover without appropriate
PPE. Refer to NFPA 70E for
PPE requirements. This panel
may contain more than one
power source.
The VS hydraulic dock leveler is designed to
compensate for a maximum +10 in. (254 mm)above
and - 8 in. (203) below dock difference between the
loading dock and the truck bed. DO NOT use the
dock leveler if the truck/trailer bed is more than 10
in. above 8 in. below higher or lower than the dock
floor.
Based on a 5 ft or 6 ft long leveler.
*service height may vary with design specifications
DO NOT overload the dock leveler.
DO NOT operate any equipment while under the
influence of alcohol or drugs.
DO NOT leave equipment or material unattended
on the dock leveler.
Failure to follow these instructions may result in
personal injury and/or damage to equipment.
8 in. (203 mm)
10 in. (254 mm)