Schwank P40U Fenwal - Manual (Page 12)

12
P40U-F / P40U-IF I&O Manual
IM101220
RD: MAY 2014
RL: 5A
IMPORTANT: Single or multiple heater placement must be such that continuous
operation of heaters will not cause combustible material or materials in storage
to reach a temperature in excess of ambient temperature plus 90F° (50C°).
It is the installer’s responsibility to ensure that building materials with a
low heat tolerance which may degrade at lower temperatures are protected
to prevent degradation. Examples of low heat tolerance materials include
vinyl siding, fabrics, some plastics, filmy materials, etc.
Refer to “Clearance to Combustibles” information on pages 6 to 8, and
Figure 1 and Table 1.
8. HEATER INSTALLATION
Inadequate or improper suspension of the tube heater can result in collapse of
the system, property damage, and personal injury or death.
It is the installer’s responsibility to ensure that the hardware and structural sup-
ports from which the heater is suspended are sound and of adequate strength
to support the weight and expansion forces of the heater.
USE CARE & CAUTION WHEN LIFTING HEATER FROM CARTON
1. DO NOT LIFT THE HEATER BY THE REFLECTOR
2. CHAINS PROVIDED ARE TO LIFT HEATER FROM CAR-
TON AND FOR HANDLING PURPOSES ONLY
3. WHEN HANDLING FROM BENEATH HEATER -
HANDLE BY TUBE NOT REFLECTOR
4. KEEP THE HEATER HORIZONTAL / LEVEL ALONG ITS
LENGTH WHILE HANDLING AND INSTALLING
5. AT LEAST 2 PERSONS ARE REQUIRED TO
LIFT AND INSTALL THIS HEATER
6. LIFT SAFELY - LIFT WITH YOUR
LEGS AND KEEP BACK STRAIGHT -
DO NOT BEND OR TWIST.
7. BEWARE - SHARP EDGES!
WEAR PROTECTIVE GLOVES AND
CLOTHING WHEN HANDLING
IMPORTANT: FIRST READ and ensure that installation adheres to the information pro-
vided on pages 4 to 8 of this manual, and all national and local codes.
Refer to Figures on next pages for figures and dimensions to assist in installation.
1. Establish the location and install the structural mounting supports and any suspension hard-
ware (chain, etc) prior to removing heater from the carton
REFER TO PAGES
12 TO 16 IN MANUAL
FOR SUSPENSION
INSTRUCTIONS