Vertical contact toaster – A.J. Antunes & Co VCT-20 9200552 User Manual
Page 31
31
VERTICAL CONTACT TOASTER
P/N 1010719 Rev. E 02/13
1
0011264
Conveyor Belt
2
0800204
1/2" Pitch Link, Small
4
0800121
3/4" Pitch Link, Large
37
2
2150117
Idler Shaft
2
3
0011329
Conveyor Cover Assy.
2
4
0010475
Tensioner Assy. (Incl. #40, 76, 85) 4
5
0800332
Rod, Conveyor Cover
4
6 2150190
Sprocket
8
7
7000199*
Spacer Kit
2
8
0503362
Control Cover
1
9
2150118
Drive Shaft
2
10 0700452
Power Cord/Plug, NEMA 6-20P (Std.) 1
0700588
Power Cord/Plug, HRN/IEC-309
1
11 7000198
Control Board
1
12 2150158
Ball Bearing
2
13 2150186
Bearing
6
14 0503459
Bearing Retainer/Spacer
6
15 0503376
Bearing Retainer
6
16 7000167
Bearing & Retainer Kit
1
(Includes #13,14,15 & 59)
17 2150181
Drive Sprocket
2
18 2150187
Drive Chain
1
19 0011299
Idler Sprocket & Bearing
1
20 0501232
Bracket, Idler Sprocket
1
21 0503589
Bracket, Motor Mounting
1
22 7000175
Drive Motor Kit, 60 Hz (Incl. #58) 1
7000240
Drive Motor Kit, Dual Frequency
50/60 Hz (Incl. #58)
1
23 2150173
Sprocket w/Setscrew, Motor
1
24 4010137
Rocker Switch, On/Off (250 VAC) 1
25 4060355
Terminal Block
1
26 405K125
Relay, Solid State
2
27 4010187
Transformer
1
28 7000192
Conveyor Belt Wrap (Pack of 2) 1
29 7000186
Roller Tensioner Assy. (Pack of 2) 1
30 0503496
Tensioner Bracket, Right
2
31 0503497
Tensioner Bracket, Left
2
32 1001037
Label, Control
1
33 10P1047*
Label, Dial (Pack of 10)
1
34 2100253
Knob, Control
2
35 0503390
Cover, End Housing
1
36 4050214
Thermocouple Assy.
1
37 0021170
Weldment, End Housing
1
38 7000110
Release Sheet (Pack of 3)
-
7000111
Release Sheet (Pack of 10)
-
39 0021169
Control Housing
1
40 7000121
Slide Rail Kit (Includes 2
slide rails for tensioners)
2
41 0021207
Conveyor Cam
2
42 7000176
Thermocouple Retainer Kit
2
43 4030332
High Limit Thermostat
1
44 040K251
Strain Relief
1
0400315
Strain Relief (9200552 only)
1
45 0400138
Locknut, 1/2"
1
46 0503590
Bracket, Motor
1
47 0700580
Wire Set (not shown)
1
48 0503385
Bun Chute
1
48A 0503677
Bun Chute (9200650 Only)
1
49 4030333
Auxiliary Heater, Air, 400 Watts 2
50 7000165
Auxiliary Thermocouple Kit
1
51 7000200
Platen (208 VOLT)
1
52 2100252
Tape
4
53 0503359
Bracket, Relay
1
54 0503150
Heater Clip
2
55 303P125*
Hinge Pin, Belt Wrap
2
56 0400312
Damper
2
57 0503533
Bracket, Auxiliary Thermocouple 1
58 4000165
Fan Blade, Motor
1
59 2100256
Tape
8
60 0011301
Damper Support Assy.
2
61 0502199
Spacer
4
62 0500464
Retainer, Bearing
1
63 0011321
Damper Assy.
1
64 0011330
Heat Shield Assy.
1
65 325P163*
Setscrew, 1/4-28 x 5/16"
8
66 100P864*
Label, Caution Hot
1
67 308P115*
Screw, #8-32 x 3/8" (10 mm)
2
68 304P105*
Nut, #4-40, "KEPS"
4
69 406P107*
Cable Tie
1
70 308P143*
Nut, #8-32, "KEPS"
6
71 310P154*
Screw, #10-32 x 3/8"
4
72 310P140*
Washer, #10
6
73 308P101*
Nut, #8-32
3
74 306P101*
Nut, Hex, #6-32
2
75 306P123*
Screw, #6-32 x 7/8"
2
76 308P145*
Nut, Hex Acorn, #8-32
14
77 100P900*
Label, Service
1
78 325P104*
Washer, 1/4"
4
79 325P109*
Screw, 1/4-20 x 1/2"
4
80 308P124*
Screw, 1-Way, #8-32 x 1/2"
1
81 10P1022*
Label, Heaters
1
82 310P136*
Screw, #10-32 x 1-1/4"
4
82A 310P180*
Screw, #10-32 x 1-3/4
(9200650 Only)
1
83 308P133*
Screw, #8-32 x 1/4"
1
84 308P151*
Screw, SEMS, #8-32 x 5/16"
4
85 308P181*
Screw, Flat Hd., #8-32 x 3/8"
4
86 218P145*
Cover, Leg, Bumper
4
87 331P103*
Shoulder Bolt, 5/16-18 x l"
1
88 306P105*
Screw, #6-32 x 1/2"
1
89 331P106*
Lockwasher, 5/16"
1
90 212P118*
Flat Washer, 5/16"
1
91 331P101*
Nut, Hex, 5/16 x 18"
1
92 300P102*
Nut, Tinnerman
2
93 210P230
Bumper, Recess Leg, 1"
4
94 0600132
Spring, Damper Support
4
95 4010107
Interlock Switch
1
96 306P104*
Screw, #6-32 x 1/4"
8
97 0503495
Retainer, Tensioner Bracket, RH 1
98 0503507
Retainer, Tensioner Bracket, LH 1
99 2120147
Spacer, Leg (9200650 Only)
4
100 1001056
Label, Crown and Heel
(9200650 Only)
1
101 2100259
Slide Bar
4
102 0503455
Tension Spring, Inner
4
* Only available in packages of 10.
Item Part No. Description
Qty.
Item Part No. Description
Qty.