JLG 3246E2 ANSI Parts Manual - Manual (Page 57)

3120738 2 -23
SECTION 2 GROUND COMPONENTS
S
E
C
T
I
O
N
2
G
R
O
U
N
D
C
O
M
P
O
N
E
N
T
S
.
FIGURE 2-6. ELECTRICAL COMPONENT INSTALLATIONS (LEFT SIDE OF MACHINES WITH
PROPORTIONAL CONTROLS)
FIG & ITEM # PART NUMBER DESCRIPTION QTY. REV.
ELECTRICAL COMPONENTS INSTALLATIONS (LEFT SIDE
OF MACHINES WITH PROPORTIONAL CONTROLS) Ref.
0259678 3246E2 Ref. D
0259678 2632E2 (Prior to S/N 104445) Ref. D
0272376 2632E2 (S/N 104445 to Present) Ref. A
0259677 2632E2 / 3246E2 (Optional with Charger Interlock) Ref. D
1 0100011 Loctite #242 A/R
2 0100048 Grease, Dialectic (Not Shown) A/R
3 0100051 Grease, Terminal A/R
4 0100076 Compound, Silicone Release A/R
5 0641404 Bolt 1/4”-20NC x 1/4” 6
6 0641405 Bolt 1/4”-20NC x 5/8” 2
7 0641408 Bolt 1/4”-20NC x 1” 4
8 0840025 Boot, Cable 8
9 Bracket, Ground Control Options: 1
Use 0902615 Prior to S/N 73083 (Was p/n 0902584)
0902615 S/N 73083 to Present
10 1060666 Cable, Battery (Contactor to Motor) 1
11 1060680 Cable, Electrical - 18/2 (Not Shown- Apply Item #3 to Termi-
nal Ends) 2ft/.6m
12 1060763 Cable, Battery (Contactor to Controller B+) 1
13 1060764 Cable, Battery (Controller A to Motor) 1
14 1600289 Controller, Smart System (Apply Item #4 on entire back
surface of unit when replacing) 1
15 2600231 Hinge 1
16 2940119 Latch, Panel 1
17 Locknut Options: 1
3300408 3246E2
3300408 2632E2 (Prior to S/N 104445)
Not Used 2632E2 (S/N 104445 to Present)
3311005 2632E2 / 3246E2 (Optional with Charger Interlock)
18 3311401 Nut 1/4”-20NC 5
19 3311402 Nut, Jam 1/4”-20NC 6
20 3311405 Locknut 1/4”-20NC 6
21 3571652 Plate, Controller Mounting 1
22 Relay, Power Options: 1
3740069 3246E2
3740069 2632E2 (Prior to S/N 104445)
Not Used 2632E2 (S/N 104445 to Present)
3740069 2632E2 / 3246E2 (Optional with Charger Interlock)
23 3740131 Contactor, Main 1
24 3910804 Screw, Round Head #8-24NC x 1/2” 3
25 Screw, Round Head #10-24NC x 1” Options: 1
3911008 3246E2
3911008 2632E2 (Prior to S/N 104445)
Not Used 2632E2 (S/N 104445 to Present)
3911008 2632E2 / 3246E2 (Optional with Charger Interlock)