JLG 4394RT Service Manual - Manual (Page 11)

SECTION 1 - SPECIFICATIONS
3121249 – JLG Lift – 1-1
SECTION 1. SPECIFICATIONS
1.1 SPECIFICATIONS 1.2 CAPACITIES
1.3 ENGINES
Table 1-1. Operating Specifications
Description 3394RT 4394RT
Maximum Occupants 6
Maximum Workload
(Capacity):
Single Extension:
Dual Extension:
Extension Only:
2250 lbs (1020 kg)
2000 lbs (905 kg)
500 lbs (230 kg)
1500 lbs (680 kg)
1250 lbs (565 kg)
500 lbs (230 kg)
Maximum Travel Grade :
2 WD
4WD
35%
45%
Maximum Travel Grade : 3°
Maximum Platform Height 33 ft (10.06m) 43 ft (13.11m)
Maximum Drive Speed 2 WD
Maximum Drive Speed 4WD 3.0 mph (4.8 kph)
3.5 mph (5.6 kph) 3.0 mph (4.8 kph)
3.5 mph (5.6 kph)
LIft Up Speed
(Stowed to Full Height)
29 - 31 sec 40 - 45 sec
Lift Down Speed
(Full Height to Stowed)
Maximum Wind Speed
28 mph (12.5 m/s)
Maximum Horizontal Manual
Side Force:
Single Extension
Dual Extension
Single Extension (CE/AUS)
Dual Extension (CE/AUS)
335 lb force (1490 N)
300 lb force (1335 N)
90 lb force (400 N)
90 lb force (400 N)
300 lb force (1335 N)
300 lb force (1335 N)
90 lb force (400 N)
90 lb force (400 N)
Maximum Tire Load 4400 lbs (1996 kg)
Ground Bearing Pressure
w/Standard tires 49 psi
(3.45 kg/cm 2 )
56 psi
(3.94 kg/cm 2 )
Leveling Jack Bearing
Pressure
69 psi (4.9 kg/cm 2 )
Wheelbase 9.67 ft (2.95 m)
Ground Clearance 12 in (30 cm)
Maximum Hydraulic System
Pressure
3000 psi (207 bar)
Electrical System Voltage 12 Volt
Inside Turning Radius 14.5 ft (4.39 m)
Outside Turning Radius 20.1 ft (6.12 m)
Gross Vehicle Weight
(with One Extension)
Note: Certain options or
country standards increase
weight.
11,910 lbs
(5,402 kg)
15,300 lbs
(6,940 kg)
Table 1-2. Capacities
Description 3394RT 4394RT
Fuel Tank 31.5 gal (119 L)
Hydraulic Tank:
Total Capacity
Full Level
Low Level
32.3 gal (122.3 L)
27.3 gal (103.3 L)
23.6 gal (89.3 L)
Table 1-3. Deutz - D 2.9 - L4 - Engine Specifications
(Tier 4 Final Engine)
Emissions EPA - Tier 4 Final
Fuel Type: Diesel
Oil Capacity 2.35 Gal. (8.9 L) w/Filter
Coolant Capacity 0.79 Gal. (3.0 L) - Engine Only
Engine RPM Control Deutz Electronic - EMR4
Low RPM Set 1200 RPM
High RPM Set 2600 RPM
Alternator 95 Amp, 12V, Belt Drive
Battery 112 Amp-Hour, 950 Cold Crank-
ing Amps, 12 VDC
Fuel Consumption: Low RPM
High RPM 1.3 GPH (4.9 lph)
1.6 GPH (6.0 lph)
Horsepower 49 Hp (36.4 Kw) @ 2600 RPM
Torque Rating 108 Ft. lb. (147 Nm) @ 1600 rpm
Cylinder Firing Order 1-3-4-2
Table 1-4. Deutz D2011 L03 T41-Flex Specifications
(Tier 4 Flex Engine)
Fuel Type: Diesel
Oil Capacity 8.5 Quarts (8 L) w/Filter
Low RPM 1200
High RPM 2800
Alternator 95 Amp, Belt Drive
Battery 112 Amp-Hour, 950 Cold Crank-
ing Amps, 12 VDC
Fuel Consumption: Low RPM
High RPM 1.3 GPH (4.9 lph)
1.6 GPH (6.0 lph)
Horsepower 49 @ 2800 RPM, full load