Marshalltown SW100H Shockwave Vibratory Screed - Manual (Page 2)

2 of 48
104 S. 8th Ave. Marshalltown, IA Phone 800-888-0127 / 641-753-0127 • Fax 800-477-6341 / 641-753-6341 www.marshalltown.com
WS570
R10-22-12
TABLE OF CONTENTS
SAFETY PRECAUTION
Safety Precaution . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Common Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Assembly Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-6
Machine Adjustments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Parts Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-9
Wet Screeding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
Form to Form Screeding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Technical Data/Capacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
Maintenance Schedule . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
How to Operate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-14
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15
This machine was built with user safety in mind, however, it can present hazards if improperly operated and serviced . Follow
operating instructions carefully and use good judgement when operating!
If you have questions about operating or servicing this equipment, please contact your
Marshalltown distributor or Marshalltown
Company at 800-888-0127 or 641-753-0127 .
ALWAYS
• Always stop engine between loads of concrete
• Always screed while walking backwards
• Always clearly mark and be aware of all grade pins,
form stakes or other trip hazards
• Always follow all safety warnings and labels of the
engine manufacturer
• Always read and understand the owners manual of
the engine manufacturer
• Always wear approved hearing, eye and breathing protection
• Always use form oil to coat blade or other parts susceptible
to concrete build up (avoiding electrical connections) before
each use
• Always properly secure screed before transporting
• Always follow recommended maintenance schedules
• Always make sure all connections and fasteners are tight
before every use
• Always always make sure engine is in "OFF" position when
servicing or not in use
• Always use in a well ventilated area
• Always keep Shockwave™ and engine manual handy
on the job site
• Always replace parts as they become damaged or worn
NEVER
• Never operate screed without all parts and safety
covers correctly attached
• Never allow children to operate
• Never operate under the influence of drugs or alcohol
• Never use screed for anything other than its
intended purpose
• Never set eccentric weights to where excessive vibration
occurs at low RPM (weights too far open)
• Never set eccentric weights to where it takes excessive
RPM to make weights vibrate (weights too far closed)
• Never allow engine to run unattended or idle on
top of wet concrete
• Never place concrete higher than the leading
“curl edge” of the blade
• Never fill gas tank while engine is running
• Never start engine near spilt fuel
• Never fill gas tank, operate, or service screed
near open flame
• Never use parts or blades from other manufacturers
• Never service a hot engine
• Never operate without proper training
• Never spray water or other liquid on a hot engine