Great Plains 3S-4000HDF Predelivery Manual - Manual (Page 13)

Assembly 11
12/10/2009 195-067Q
Install Reflectors and Decals
To prevent scuffing in shipment, walkboard decals are
shipped in a bag in one of the drill boxes, and are applied
after final field assembly.
The precise location of the outside wing decals depends
on whether a fixed step or swing-down ladder is installed.
To install new reflectors and decals:
• Clean and dry the area where the reflector or decal is
to be placed.
• Peel backing from reflector or decal. Press firmly on
surface, being careful not to cause air bubbles under
reflector or decal.
Center and Inner Decals
Refer to Figure 10
Starting on the left end of the center walkboard:
1. Place one 838-266C Red decal on the rear-facing
outside end of the walkboard. Align the outside end of
the decal with the walkboard corner.
2. Place one 838-265C Amber decal on the outside end
of the walkboard
. Align the rear end of the decal
with the walkboard corner.
3. Place one 838-267C Daytime decal on the rear face
of the walkboard
, just inboard of the red decal .
Align the outside end of the decal with the inside end
of the red decal.
4. Repeat for right end of center section walkboard.
Fixed Step Decals
If the drill is equipped with a swing-down ladder, skip
these steps and use the instructions at “Swing-Down
Ladder Decals” on page 12.
Refer to Figure 11
Starting on the left wing walkboard:
1. Place the 838-102C Danger Falling Hazard decal
on the outside end of the walkboard, just aft of the
step’s vertical riser, where it is visible to climbers.
2. Place one 838-265C Amber decal on the outside
(step) end of the walkboard
. Align the rear end of
the decal with the walkboard corner.
3. Place one 838-265C Amber decal on the rear face of
the walkboard, step end
. Align the rear end of the
decal with the walkboard corner.
4. Repeat for right wing section walkboard.
5. Skip to “Other Assembly Items” on page 12.
Figure 10
Center Walkboard Decals
27019
3
1 2
1
2
3 1
Figure 11
Fixed Step Ladder Decals
27017
3
1
2
1
2
3