7routine maintenance – Tempest Thunder User Manual
Page 22
Thunder Enclosure User Manual
page
22
7
Routine Maintenance
It is very important to perform routine maintenance on both the enclosure and the equipment inside it.
Failure to do so may reduce lifetime for both the enclosure and the equipment.
Note
Maintenance schedules depend on location and environment. The intervals given here are
general minimum guidelines. It is up to the user to judge whether maintenance should be carried out
more frequently. We recommend doing these tasks no less often than mentioned here.
Safety
As the enclosure is a powered unit with moving parts, it is necessary to keep safety in mind
while performing routine maintenance. Although maintenance can be performed while the enclosure is
powered, it is safer to carry it out with the power disconnected with proper lockout and tag out
procedures followed.
Be aware that once the enclosure has had power applied to it, the fan will start to turn. Make
sure that your hands are clear of the fan before applying power to the enclosure.
Only authorized personnel should perform maintenance on the enclosure or equipment
Do not service the unit in the rain or other adverse weather conditions (snow, sleet, high
winds, etc.).
Inspection Checklist: - Every Three (3) Months
Glass should be clean and free of cracks
Enclosure should be free of debris both inside and out
Bolts and tie-down straps should be tight
Rubber seals should be in good condition. Check seals inside and out for gaps.
Fan hould be functioning and not making excessive noise
Filters should be clean
Air Filter - Every Three (3) Months
The air filter should be removed and cleaned on a regular basis. To remove filter, pull pull it directly
out of the intake vent. The filter can be cleaned by running water from a hose and do not require any
special solution.
To reinstall, carefully push filter back into the cowl molding.
Case - As Needed
The outside of the case should be cleaned as needed. The case should be cleaned with a wet
cloth and mild detergent (if necessary). Do not use a direct spray from a hose to clean the case.
Equipment
Review the manufacturer's instructions for proper maintenance of your Luminaire. Remember,
the enclosure simply protects the equipment inside it and is not a substitute for regular maintenance.