Fulton Vantage (VTG) Fully Condensing Hydronic Boiler - Manual (Page 10)

© The Fulton Companies 2013
INSTALLATION
VTG-IOM-2013-0815
SECTION 2
2-4
TABLE 1 - BOILER DIMENSIONS AND OPERATING REQUIREMENTS
MODEL VTG
2000 2000DF 2500 2500DF 3000 3000DF 3500 3500DF 4000 4000DF 5000 5000DF 6000 6000DF
Specifi cations 2000LE 3000LE 4000LE
Input Million BTU/Hr.
kW
2
586
2
586
2.5
733
2.5
733
3
879
3
879
3.5
1026
3.5
1026
4
1172
4
1172
5
1465
5
1465
6
1758
6
1758
Fuel Cons. @ rated cap: (Nat. Gas) FT 3 /Hr.
M 3 /Hr
2,000
56.6
2,000
56.6
2,500
70.8
2,500
70.8
3,000
84.9
3,000
84.9
3,500
99.1
3,500
99.1
4,000
113.2
4,000
113.2
5,000
141.5
4750
134.5
6,000
169.9
6,000
169.9
Fuel Cons. @ rated cap.: (#2 Oil) GPH
LPH
NA
NA
14.3
54.1
NA
NA
14.3
54.1
NA
NA
21.4
81.0
NA
NA
21.4
81.0
NA
NA
28.6
108.2
NA
NA
27.17
102.8
NA
NA
42.8
162.0
Output at AHRI Test Condition BHP
KCal/h
57
4.8
57
4.8
69
5.8
69
5.8
86
7.25
86
7.25
96
8.0
96
8.0
116
9.7
116
9.7
138
11.6
138
11.6
168
14.1
168
14.1
Electrical Req. (Amps) 230V, 60Hz, 3 Phase 6.8 13.4 12.9 16.1 12.9 16.1 18.5 16.1 18.5 16.1 23 29.2 23 29.2
460V, 60Hz, 3 Phase 3.4 6.7 6.5 8.1 6.5 8.1 9.3 8.1 9.3 8.1 11 16.6 11 16.6
Water Content Gal
Liters
147
556.4
147
556.4
147
556.4
147
556.4
215
813.8
215
813.8
215
813.8
215
813.8
275
1041
275
1041
275
1041
275
1041
480
1817
480
1817
Dry Weight LB
KG
3,800
1724
3,800
1724
3,800
1724
3,800
1724
5,200
2359
5,200
2359
5,200
2359
5,200
2359
5,800
2631
5,800
2631
5,800
2631
5,800
2631
9,950
4513
10,800
4899
Operating Weight LB
KG
5,100
2314
5,100
2314
5,100
2314
5,100
2314
7,000
3175
7,000
3175
7,000
3175
7,000
3175
8,100
3674
8,100
3674
8,100
3674
8,100
3674
13,950
6327
14,800
6713
Dimensions
A. Boiler Width IN
CM
30.5
77.5
30.5
77.5
30.5
77.5
33.6
85.3
34.65
88.0
34.5
87.6
34.6
87.8
34.5
87.6
40.5
102.8
40.5
102.8
40.5
102.8
40.5
102.8
50.5
128.2
50.5
128.2
B. Overall Boiler Height IN
CM
64
162.5
64
162.5
76
193
72.8
184.9
87
220.9
70.5
179.0
83.9
213.1
76.1
193.2
87.6
222.5
78
198.1
87.6
222.5
79.5
201.9
90
228.6
90
228.6
C. Overall Boiler Depth IN
CM
108
274.3
122
309.8
108
274.3
120
304.8
120
304.8
132
335.2
120
304.8
132
335.2
124
314.9
136
345.4
136
345.4
136
345.4
155
393.7
155
393.7
D. Flue Outlet Diameter IN
CM
10
25.4
10
25.4
10
25.4
10
25.4
12
30.4
12
30.4
12
30.4
12
30.4
14
35.5
14
35.5
14
35.5
14
35.5
14
35.5
14
35.5
E. Air Inlet Diameter IN
CM
8
20.3
10
25.4
10
25.4
10
25.4
10
25.4
10
25.4
10
25.4
10
25.4
12
30.4
12
30.4
12
30.4
12
30.4
12
30.4
12
30.4
F. Water Inlet/Outlet Diameter IN
CM
4
10.1
4
10.1
4
10.1
4
10.1
4
10.1
4
10.1
4
10.1
4
10.1
6
15.2
6
15.2
6
15.2
6
15.2
6
15.2
6
15.2
G. Min. Clearance to Ceiling IN
CM
24
60.9
24
60.9
24
60.9
24
60.9
24
60.9
24
60.9
24
60.9
24
60.9
24
60.9
24
60.9
24
60.9
24
60.9
24
60.9
24
60.9
H. Overall Height (w/o blower) IN
CM
68.1
172.9
64
162.5
64
162.5
68.1
172.9
76.2
193.5
70.5
179.0
76.2
193.5
76.2
193.5
78.5
199.3
78.0
198.1
79.5
201.9
79.5
201.9
90
228.6
90
228.6
Clearances and Serviceability
Adhere to the following for clearances and serviceability:
1. All local and national codes (NFPA, ANSI, UL, CSA,
ASME) must be followed for proper clearances and
serviceability for your boiler or heater. Authorities
having jurisdiction should be consulted before
installations are made.
2. Appropriate front, back, side and top clearances must
be maintained (Figure 1). This will allow access around
the equipment to facilitate maintenance and a safe
* Alternate gas pressure arrangements may apply. Please verify gas pressure ratings for your boiler by viewing the boiler name plate.
** Typical 120 VAC controls allow for a +10% and a -15% voltage fl uctuation.
***Standard confi gurations. Alternate voltages available as an option; please consult factory.
Note: All dimensions are approximate and are subject to change without notice.
The use of propane may be allowable with concentrations up to 5% propylene, also referred to as HD5. Off -standard grades of propane are not permitted. Contact
factory for more information.