Flex-a-Lite 56418 Camaro Radiator Only Kit Fits 2010-2011 Chevrolet Camaro - Manual (Page 5)

Secure the top radiator hoses to radiator inlet tube after you have filled the cooling system utilizing the 13.
provided hose clamp. (see Detail M on previous page) Top off radiator coolant level as necessary and
attach supplied 20psi. radiator cap. Remember to fill reservoir to cold fill level. Check for leaks before
proceeding.
Note: BE SURE that all moving parts of the engine and electric fan (where applicable) are clear of
each other before proceeding!!
Reattach air cleaner outlet duct with attached PCV tube back onto previous mounting points. Tighten large
14.
hose clamps (2ea) and reattach PCV tube back to manifold connection point.
Reconnect electrical plug back onto mass air flow sensor located on outlet tube of the air filter housing.
15.
Remove oil filler cap. Reattach large plastic engine cover in opposite order of how it was removed. Reattach 16.
oil filler cap.
Reconnect the negative (-) battery cable inside the trunk compartment.
17.
Start vehicle and idle until it has reached normal operating temperature. The electric fans should cycle on 18.
and off to regulate engine coolant temperature.
After electric fan operation has been verified turn vehicle off and allow coolant to return to ambient
19.
temperature. Check coolant levels of reservoir and radiator topping off as needed.
Note:
20. We suggest following the vehicle manufactures recommended transmission fluid level checking and
filling procedure before operating the vehicle on the road. The transmission on this vehicle does not come
equipped with a fill tube and dipstick.
Installation instructions continued from previous page
Rev. 02-02-12 98488 Page 5 of 5
The Flex-a-lite Limited Warranty
Flex-a-lite Consolidated, 7009-45th St. Ct. E. Fife, WA 98424, Telephone No. 253-922-2700, warrants to the original purchasing user, that all Flex-a-lite
products to be free of defects in material and workmanship for a period of 365 days (1 year) from date of purchase. Flex-a-lite products failing within
365 days (1 year) from date of purchase may be returned to the factory through the point of purchase, transportation charges prepaid. If, on inspection,
cause of failure is determined to be defective material or workmanship and not by misuse, accidental or improper installation, Flex-a-lite will replace the
product free of charge, transportation prepaid. Flex-a-lite will not be liable for incidental, progressive or consequential damages. Some states do
not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply to you. This warranty gives
you specific legal rights and you may have other rights, which vary from state to state. The Flex-a-lite warranty is in compliance with the Magnuson-Moss
Warranty Act of 1975.
Limited Radiator Warranty
Flex-a-lite Consolidated warrants its aluminum radiators to be free from defects in materials and workmanship
for a period of one year from the date of purchase at retail by the original purchaser. This warranty is extended
only to the first purchaser of any such radiator at retail. If the Flex-a-lite radiator is used in any racing application,
repaired or altered, this warranty is considered null and void, it also does not cover any radiator repaired or
altered in any way. If products such as transmission cooler or electric fan are attached with cable ties or similar
fasteners that run through the radiator core, the warranty is voided.
This warranty does not cover labor, materials not manufactured by Flex-a-lite, or shipping charges. The retail
purchaser is responsible for the appropriate use and application of the product. This warranty does not cover the
effects of physical or chemical properties of water, steam, or other liquids used in the radiator. Radiators used
without an adequate proportion of premium quality antifreeze/coolant are not covered by this warranty. Flex-a-lite
aluminum radiators require a correct proportion of quality coolant, which contains aluminum corrosion inhibitors in
the formula.
Claims for internal damage of the engine, components, or user’s vehicles are not covered by this warranty. It is
the responsibility of the Flex-a-lite product user to monitor engine operation and have proper detection devices
installed to warn the user of overheating. Specific exemptions to the warranty include tube damage, ballooning
or bursting from excessive engine operating temperature, internal corrosion due to inadequate proportions of
antifreeze/coolant, or damage to radiator resulting from a collision damage.
Flex-a-lite shall not be responsible for damages to its product or injury to persons using the product when
improperly opening radiator pressure caps, burst hoses, etc. Flex-a-lite shall not be responsible for injury or harm
to persons or property caused by persons or vehicles using our products.
The purchaser’s remedy for breach of this warranty, exclusive of all other remedies provided by law, is expressly
limited to repair or replacement of any part or parts. All products returned for warranty consideration must be
returned through the point of purchase with all transportation expenses prepaid. Upon receipt of the product,
Flex-a-lite will examine the product to determine the condition and validity of the claim.
Radiators or products received, which were damaged in shipping, should immediately be reported to the shipping
carrier as damaged, and claims of damage filed accordingly. Contact the transport carrier (UPS, truck line, etc.)
for procedures in filing damage claim with the carrier or their agent. Do not return product damaged in shipping
to Flex-a-lite.
Some states may not allow a limitation on the duration of any implied warranty. The above warranty may not
apply to you. This warranty grants you specific legal rights, and you may have other rights, which vary from state
to state.