Vortech 1994-1995 Ford 5.0 Mustang - Manual (Page 23)

P/N: 4FG020-010
© 2008 Vortech Engineering, Inc.
All Rights Reserved. Intl. Copr. Secured
04NOV08 V2.0(94-95 5.0 Mus.(4FG V2.0))
15
18. T-REX ® FUEL PUMP INSTALLATION cont'd.
NOTE: Make sure everything is secure and away from all moving parts
or exhaust pipes. Make sure no wires will rub on sharp edges.
After you have activated the pump, check for any leaks and
correct if necessary.
Fig. 18-a
T-REX ®
MAGNIFICATION OF RELAY WIRING
86
GROUND
RELAY
30
87A
85
87
(+)T-REX FUEL PUMP
RED/PURPLE WIRE
IN STOCK HARNESS
LUG FROM BATTERY
TO FUSE PANEL
UNDER HOOD
Route the red power lead from the relay #30 under the car through the drive shaft
tunnel and secure with ties! Take care to avoid sharp edges and not damage the
wire insulation. Mount relay in the right rear corner of the spare tire well. Make sure
all wires are connected as per the relay schematic below. Provide a good ground
connection free of rust and paint for both the pump and relay.
(Check with test light when key is
turned to “ON” position. Test light
should illuminate for 2-3 seconds,
then it should turn “OFF”
automatically.)
-
+
5/16" x 16-1/2" HOSE
MAGNIFICATION - UNDERSIDE VIEW
FUEL TANK STRAP
T-REX FUEL PUMP
3/8" x 22" HOSE
11" CABLE TIES
CABLE TIE
FLEX LOOM
FROM FUEL
TANK
FRONT OF CAR
STOCK HOSE
ASSEMBLY
FROM TANK
FLOW
STOCK FUEL FILTER
AND BRACKET
FLOW
FRONT
OF CAR
20 AMP
INLINE
FUSE
HIGH CURRENT
FUSE PANEL
WITH POWER
LUG FROM
BATTERY
DRIVE
SHAFT
TUNNEL
SPARE
TIRE WELL
Pump is mounted below the tire well, under the car.
Secure wires with adhesive anchors and tie wraps.