DR Power 8.25 Pro Power Wagon (February 2007 - February 2009) - Manual (Page 38)

34 DR
®
POWERWAGON-PRO
End of Season and Storage
WHEN PERFORMING ANY MAINTENANCE, YOU MUST FIRST SHUT OFF THE ENGINE, SET THE
PARKING BRAKE, WAIT FIVE (5) MINUTES TO ALLOW PARTS TO COOL AND DISCONNECT THE SPARK
PLUG WIRE, KEEPING IT AWAY FROM THE SPARK PLUG.
NOTE: Please refer to the Engine Owner's Manual for Engine-specific procedures.
•
Change the oil; this will help to eliminate sludge and acids in the Engine. For winter use, use SAE 5W
– 30W.
•
If your DR POWERWAGON-PRO will be idle for more than 30 days, we recommend using a gas
stabilizer. This will prevent sediment from gumming up the carburetor. If there is dirt or moisture in
the gas or tank, remove it by draining the tank. Completely fill the tank with fresh, unleaded gas and
add the appropriate amount of stabilizer or gasoline additive. Run the Engine for a short time to
allow the additive to circulate.
•
Remove the Spark Plug and pour about 1 ounce of motor oil into the cylinder hole. Replace the Plug
and pull the Recoil Starter Rope until you feel strong resistance. This will coat the piston and seat the
valves to prevent moisture buildup.
•
Clean and/or replace the Air Filter(s).
•
Clean dirt and debris from the cylinder head cooling fins, carburetor linkage, blower housing, rotating
screen, and muffler area of the Engine.
•
Check to make sure the operator controls are moving freely. Lubricate the Throttle Lever, Parking
Brake Lever, and Key Switch with SAE 30 Oil if necessary. See page 22.
•
Electric starting models: Remove the Battery and keep it in a cool, dry place when the DR
POWERWAGON-PRO is in storage. We suggest charging the Battery once a month while the DR is
stored, and again before you are ready to start the new season. This will help the Battery maintain its
charge all season. See page 20.