DR Power 8.25 Pro Power Wagon (February 2007 - February 2009) User Manual
Page 41
CALL TOLL-FREE 1-800-DR-OWNER
37
WHEN PERFORMING ANY MAINTENANCE, YOU MUST FIRST SHUT OFF THE ENGINE, SET THE
PARKING BRAKE, WAIT FIVE (5) MINUTES TO ALLOW PARTS TO COOL AND DISCONNECT THE SPARK
PLUG WIRE, KEEPING IT AWAY FROM THE SPARK PLUG.
S
YMPTOM
P
OSSIBLE
C
AUSE
The Belt frays or
rolls over the
Pulley.
⇒ There may be a nick in a Pulley groove. Check the Belt for wear and hard spots.
File off any nicks on the Pulley.
⇒ Check the Belt Guide alignment. See page 23.
⇒ The Belt may be stretched, replace it.
Machine is hard to
get into Reverse.
⇒
The Shift Lever may need adjusting. See page 31.
Wheels pulling left
or right.
⇒ Check the tire(s) pressure. See page 10.
Machine lacks
traction.
⇒ The load may be uneven in the Bed. The more weight over the Wheels the better
the traction.
⇒ Try a lower gear.
⇒ If you are working on rough terrain with Turf tires, you may want to consider the
All-Terrain tires. Call 1-800-DR-OWNER (376-9637) for information.
The Wheels will
not turn.
⇒ Make sure that the DR POWERWAGON-PRO is in gear.
⇒ Check that the Parking Brake is off.
⇒ The Drive Belt may be loose or off the Pulley. See page 24.
⇒ The Drive Belt may be on the wrong side of the Pulley. See page 24.
⇒ If the Wheels still will not turn, call 1-800-DR-OWNER (376-9637) for assistance.
The Electric Dump
System is not
responding.
⇒ There is a Fuse under the Control Panel. Check the Fuse and replace if needed.
⇒ Check for loose electrical connections.
⇒ Check to be sure the Key Switch is in the ON position to operate the Electric Dump
System. See Figure 6 on page 13.
⇒ Check the Battery charge. If the Key activates the Starter, the Battery is sufficiently
charged. If it does not start the Engine, charge the Battery and repeat.
⇒ If the Electric Dump System still will not respond, call
1-800-DR-OWNER (376-9637) for assistance.
The Dump Bed
stops with the
Switch Button
depressed.
⇒ Release the Switch and try the opposite direction. If the Dump Bed moves, check
the area beneath the Dump Bed for obstructions.
⇒ If the Dump Bed does not move in the opposite direction, check the Battery and
connections as above.
⇒ If the Dump Bed still stops, call 1-800-DR-OWNER (376-9637) for assistance.