Sharp FODC550 - Manual (Page 109)

MATERIAL SAFETY DATA SHEET
Date Rivised: Mar. 1. 2004
Date Issued: Sep. 1. 2003
MSDS No. F-31231
107
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Engineering Measures
Ventilation : Not required under intended use.
Exposure Limit Values
OSHA-PEL (USA) : 15mg/m 3 (Total Dust), 5mg/m 3 (Respirable Dust)
ACGIH-TLV (USA) : 10mg/m 3 (Total Dust), 3mg/m 3 (Respirable Dust)
Personal Protective Equipment
Respiratory Protection : Not required under intended use.
Hand Protection : Not required under intended use.
Eye Protection : Not required under intended use.
Skin Protection : Not required under intended use.
Other Protective Equipment : Use of a dust mask and goggles are recommended when
handling a large quantity of toner or during long term exposure,
as with any non-toxic dust.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance
Physical State: Solid Form: Powder Color: Black Odor: odorless
Ph : Not applicable
Boiling / Melting Point : Not applicable
Softening Point (°C)
: 130°C (toner)
Flash Point (°C) : Not applicable
Ignition Point (°C) : No data
Explosion Properties : No data
Density (g/cm 3 ) : 7
Solubility in Water : Negligible
10. STABILITY AND REACTIVITY
Stability : Stable
Hazardous Reactions : Dust explosion, like most finely divided organic powders.
Conditions to Avoid : Electric discharge, throwing into fire.
Materials to Avoid : Oxidizing Materials
Hazardous Decomposition Products: CO, CO
2
and NO
X
Further Information : None
11. TOXICOLOGICAL INFORMATION
Acute Toxicity
Ingestion (oral) : LD 50 > 2000mg/kg (Rats)
Inhalation : LC 50 > 5.14mg/L (Rats)
Eye irritation : Not an irritant (Rabbits)
Skin irritation : Not an irritant (Rabbits)
Skin sensitizer : No data
Mutagenicity : Negative (Ames Test).
Carcinogenicity : In 1996 the IARC reevaluated carbon black as a Group 2B carcinogen
(possible human carcinogen). This classification is given to chemicals for
which there is inadequate human evidence, but sufficient animal evidence on
which to base an opinion of carcinogenicity. The classification is based upon
the development of lung tumors in rats receiving chronic inhalation exposures
to free carbon black at levels that induce particle overload of the lung. Studies
performed in animal models other than rats did not show any association
between carbon black and lung tumors. Moreover, a two-year cancer bioassay
using a typical toner preparation containing carbon black demonstrated no
association between toner exposure and tumor development in rats.
Page: 3/4
FO-DC550_Copy(Sec).book 107 ページ ２００４年３月２５日 木曜日 午後３時４４分