Lincoln Electric POWER WAVE 355M - Manual (Page 12)

INSTALLATION A-4 A-4
POWER WAVE 355M/405M
Retur
n
to
Section
T
OC
Retur
n
to
Section
T
OC
Retur
n
to
Section
T
OC
Retur
n
to
Section
T
OC
Retur
n
to
Master
T
OC
Retur
n
to
Master
T
OC
Retur
n
to
Master
T
OC
Retur
n
to
Master
T
OC
ELECTRIC SHOCK can kill.
• TURN THE INPUT POWER OFF AT
THE DISCONNECT SWITCH BEFORE
ATTEMPTING TO CONNECT OR DIS-
CONNECT INPUT POWER LINES, OUTPUT
CABLES, OR CONTROL CABLES.
• Only qualified personnel should perform this
installation.
• Connect the green/yellow lead of the power cord
to ground per U.S.National Electrical Code.
----------------------------------------------------------------------
WARNING
SAFETY PRECAUTIONS
SELECT SUITABLE LOCATION
In order to assure long life and reliable operation,
the owner of this machine should follow these sim-
ple preventative measures:
• The machine must be located where there is free cir-
culation of clean air such that air movement in the
back, out the sides and bottom will not be restricted.
• Dirt and dust that can be drawn into the machine
should be kept to a minimum. Failure to observe
these precautions can result in excessive operating
temperatures and nuisance shutdown.
• Keep machine dry. Shelter from rain and snow. Do not
place on wet ground or in puddles.
• DO NOT MOUNT OVER COMBUSTIBLE SURFACES.
Where there is a combustible surface directly under
stationary or fixed electrical equipment, that surface
shall be covered with a steel plate at least .06”(1.6mm)
thick, which shall extend not less than 5.90”(150mm)
beyond the equipment on all sides.
STACKING
POWER WAVE 355M/405M cannot be stacked.
TILTING
Place the machine directly on a secure, level surface or
on a recommended undercarriage. The machine may
topple over if this procedure is not followed.
INPUT AND GROUNDING CONNECTIONS
• Only a qualified electrician should connect the
POWER WAVE 355M/405M. Installation should be
made in accordance with the appropriate National
Electrical Code, all local codes and the information
detailed below.
• When received directly from the factory, multiple volt-
age machines are internally connected for the highest
voltage. Always double-check connections before
powering up the machine.
• Initial 200VAC - 415VAC and 575VAC operation will
require an Input voltage panel setup.
CAUTION
• Open the access panel on the rear of the machine.
• For 200 or 230: Position the large switch to 200-
230.
For higher voltages: Position the large switch to
380-575.
• Move the "A" lead to the appropriate terminal.
POWER CORD CONNECTION
A power cord is provided and wired into the machine.
Follow the power cord connection instructions.
• Incorrect connection may result in equipment
damage.
Single Phase Input (PW 355M)
Connect green lead to ground per National Electrical
Code.
Connect black and white leads to power.
Wrap red lead with tape to provide 600V insulation.
Three Phase Input (PW 355M)
Connect green lead to ground per National Electric
Code.
Connect black, red and white leads to power.
Single Phase Input (PW 405M)
Connect green/yellow lead to ground per National
Electrical Code.
Connect blue and brown leads to power.
Wrap black lead with tape to provide 600V insulation.
Three Phase Input (PW 405M)
Connect green/yellow lead to ground per National
Electric Code.
Connect black, blue and brown leads to power.
W AR NIN G RE M OT E
PO W ER
OF F
ON
A A MPS
A
V V OLTS
W EL D T ER M IN AL S SE LE C T
OUTP UT LIN CO LN EL EC TR IC IN VE R TE C V 35 0-P R O
W AR N IN G W AR N IN G AV IS O D E PR EC AU C IO N
AT TE N TIO N
!
!
!
!
Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g
elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t
elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t
elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t
elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t
la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t
elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t
la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing
Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t
Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t
elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing
Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g
elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t
elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t
elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing
Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing
Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g
elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t
elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t
la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing
Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g
elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t
elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t
la ore et d olo re m ag na aliq ua m era t
lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing
Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g
elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t
elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t
la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing
Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g
elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t
elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t
la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t
Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing
Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t Lo rem ip su m do lor sit am et c on se cte tue r a dip isc ing Lo rem ips um do lor sit am et co ns ec tetu er ad ipis cin g elit , e d d iam no nu m m y n ibh eu ism od tin cid un t u t
elit , e d dia m no nu m m y nib h eu ism od tin cid un t u t la ore et d olo re m ag na aliq ua m era t lao ree t d olo re m ag na aliq ua m era t
CAUTION
Machine
PW 355
PW 405
Cord Length
10 Feet
5 Meters
Lead Color Single Phase Three Phase
Connect to
ground per NEC
Power Lead
Power Lead
Power Lead
Connect to
ground per NEC
Power Lead
Power Lead
Tape, provide
600V insulation
Green
Black
White
Red