Merrychef eikon e3 - Manual (Page 22)

22 Service & Parts Manual original Instructions
Part Number 32Z3812 US
Issue 1
PR
ODUC
T
DE
TAILS
2
3
3
4
1
1
2
1 2 3
Complete COOL DOWN procedure and allow the oven and
accessories to cool before commencing cleaning.
REMOVE & CLEAN Oven Parts:
1. Remove the air filter at the base of the oven.
2. Open the oven door and lift out the turntable.
3. For ovens with a catalytic converter; open the oven door
and undo fasteners to remove the catalytic convertor when
required or at least once a month.
Wash all parts in warm soapy water. Wash off using a clean
cloth and plenty of clean, warm water.
Dry using a fresh, clean cloth.
Cold oven CLEANING INSTRUCTIONS e3 11
DO NOT USE TOOLS
CLEAN THE OVEN:
1. Remove any spillages with disposable paper wipes.
Use a dry clean brush to remove any food particles from
between the oven floor and the inside of the front door.
2. Wear protective rubber gloves and protective glasses,
carefully spray a non-caustic proprietary branded Oven
Cleaner onto all the internal surfaces of the oven except
the door seal (A).
DO NOT spray directly into the fan opening at the rear
inside of the oven.
3. For difficult areas, leave to soak for 10 minutes with the
oven door open.
Use a non–abrasive nylon scrub pad/sponge to clean the
cavity, roof and the inside of the door. Do not scrub the
door seal or use metallic scourers.
4. Wash off using a clean cloth and plenty of clean warm
water and dry using a fresh clean cloth or paper towel.
Replace all the cleaned oven parts.
Close the oven door and wipe the outside of the oven with
a damp cloth.
APPLY OVEN PROTECTOR:
1. Only apply to a clean oven. Spray proprietary branded
Oven Protector onto a sponge.
2. Spread Oven Protector lightly onto all internal surfaces
of the oven.
3. Spread Oven Protector lightly onto the internal surface
of the oven door avoiding the door seal.
Switch on the oven and preheat. When the oven has
reached operating temperature it will take about 30mins to
cure the Oven Protector.
Note: Oven protector turns light brown when cured.
DO NOT USE THE OVEN WITHOUT A CLEAN AIR
FILTER IN PLACE
A