Labconco SteamScrubbe & FlaskScrubbe Glassware Washers 45781 Series - Manual (Page 29)

Chapter 4: Using Your Washer
Product Service 1-800-522-7658 25
Glassware should be loaded so that it does not touch during a wash cycle. The
washer has been designed for quiet operation. To prevent noise and glass
breakage, be certain that glassware is retained.
The Detergent Dispenser
Your Glassware Washer is equipped with a detergent dispenser that contains a
main wash cavity and a neutralizing solution port, as shown below. In addition,
the washer door has a depression where detergent may be added for use during the
first wash of the cycle.
The detergent dispenser opens during the second wash cycle, except when the
Plastic cycle is selected, which has only one wash cycle. If your glassware is
heavily soiled, you may want to add powder detergent to the depression in the
washer door. Do not use liquid detergent in the pre-wash cavity in the washer
door. The initial drain and fill cycle flushes the liquid detergent out of the washer
prior to the first wash. Refer to the table below to determine which cavities to fill,
based on the selected wash choice. You may use either the pre-wash cavity
stamped in the washer door or the one on the lid of the detergent cup.
Wash Cycle Fill Pre-wash Cavity Fill Main Cavity
Rinse Only NO NO
Plastic NO YES
All other cycles OPTIONAL YES
Do not use combustible solvents in the Glassware Washer. If
soiled glassware contains flammable compounds, rinse the
glassware thoroughly prior to placing the glassware into the
washer. Heaters in the washer are very hot and could ignite
flammable solvents.
!
Main wash cavity
Neutralizing solution
dispenser cover
Neutralizing
solution port
Neutralizing
solution dial