Woodstock W1820 - Manual (Page 54)

-52-
Df[\cN(/(0&N(/)' D]^%J`eZ\()&('
FG
<
I
8
K@FEJ
+% Attach the auxiliary fence to the standard fence and
set it to the desired width.
Efk\1N_\e]`^li`e^flkk_\Zfii\Zkn`[k_#[fefk
]fi^\kkfXZZflek]fiYcX[\b\i]Xe[k_\`eXZZliXZp
f]k_\]\eZ\jZXc\n_`c\k_\Xlo`c`Xip]\eZ\`j
`ejkXcc\[%Kpg`ZXccp`k`jY\jkkflj\Xd\Xjli`e^
kXg\kfj\kk_\]\eZ\%
,% Place the workpiece against the auxiliary fence and
slide the resaw barrier against the workpiece, as
shown in
=`^li\68. Now clamp the resaw barrier to
the top of the table saw at both ends.
-% Slide the workpiece over the blade to make sure it
moves smoothly, then remove the workpiece.
.% Raise the blade approximately an inch, or close
to half the height of the workpiece ( =`^li\69),
whichever is less.
/% Plug in the table saw, turn it FE, and use a push
stick or push block to feed the workpiece through
the blade, using a slow and steady feed rate.
0% Flip the workpiece end for end, keeping the same
side against the fence, and run the workpiece
through the blade.
('% Repeat Jk\gj.Æ0 until the blade is close to half
of the height of the board to be resawn. The ideal
completed resaw cut will leave a
1 ⁄
8
" connection
when the resawing is complete as shown in =`^li\
69. Leaving a 1 ⁄
8
" connection will reduce the risk of
kickback.
((% Turn F== the table saw, then separate the parts of
the workpiece and hand plane the remaining ridge to
remove it.
()% When finished resawing, remove the resaw barrier
and auxiliary fence, then re-install the blade guard/
spreader or riving knife and standard table insert.
=`^li\-/. Ideal resaw workpiece setup.
8lo`c`Xip
=\eZ\
=\eZ\ I\jXn
9Xii`\i
Nfibg`\Z\ (Front View)
=`^li\69% Ideal completed resaw cut.
8lo`c`Xip
=\eZ\
=\eZ\
I\jXn
9Xii`\i
( &
/
:fee\Zk`fe
Nfibg`\Z\
8cnXpjlj\glj_jk`Zbjfiglj_gX[[c\j
kf `eZi\Xj\ jX]\kp Xe[ Zfekifc [li`e^
fg\iXk`fejn_`Z_i\hl`i\k_Xkk_\YcX[\
^lXi[ Xe[ jgi\X[\i dljk Y\ i\dfm\[
]ifdk_\jXn%8CN8PJi\gcXZ\k_\YcX[\
^lXi[X]k\ii\jXn`e^`jZfdgc\k\%
K_\ [Xe^\i f] b`ZbYXZb `eZi\Xj\j
i\cXk`m\ kf k_\ [\gk_ f] X Zlk% I\[lZ\
k_\i`jbf]b`ZbYXZbYpdXb`e^dlck`gc\
gXjj\j kf XZ_`\m\ k_\ [\j`i\[ [\gk_ f]
Zlk% =X`cli\ kf ]fccfn k_\j\ nXie`e^j
Zflc[i\jlck`ej\i`fljg\ijfeXc`ealip%