Alto-Shaam MN-28656 - Manual (Page 20)

C O N T R O L O P E R AT I O N
18.
C H E F O P E R AT I N G T I P S
1.
For cooking specific products, refer to
individual cook and hold instructions.
2.
When cooking at 250°F (121°C), it takes
approximately one hour for the cooking
temperature to decrease to the selected
holding temperature. During this one hour
time period, the product will continue to cook.
3.
The cooking times in this guide are based on
meat taken directly from a refrigerated
temperature of 38° to 40°F (3.3° to 4.4°C), and
placed in a preheated oven. Adjustments must
be made for cooking products at other than
refrigerated temperatures.
4.
It is recommended the oven door remain
closed during the cooking cycle. Opening the
door will only increase the length of time
necessary to cook the product.
5.
Puncturing an item with any sharp instrument
may introduce bacteria inside the product.
Avoid using a fork to handle products, and
always use standard sanitary methods when
handling any food item.
6.
Use a metal-stemmed thermometer to check
the internal temperature of a product. Be
certain to sanitize the thermometer before
each use.
7.
Aged meat will cook faster, shrink more,
and cannot be held as long as fresh meat.
Because of the tenderizing capabilities of
the oven, aged meat or tenderizing agents
such as M.S.G. are not necessary, and are
not recommended.
8.
When cooking full loads, never cook below
the first shelf spacing from the bottom of the
oven compartment.
9.
Fully clean the oven
interior, drip pan,
shelves, and side racks
on a daily basis.
10.
Since there is no air movement inside the
Halo Heat
®
low temperature cooking and
holding oven, condensation will form on the
inside of the door during operation and may
leak out of the oven door vents. This is a
normal operating condition; however, any
condensation spilling on the floor should be
periodically wiped as a safety precaution.
There is an External Drip Tray included as
standard with most ovens.
11.
Drip pan overflow is a condition caused by
cooking some cuts of beef to an internal
temperature in excess of 130°F (54°C). The
External Drip Tray will help alleviate some of
this overflow problem. There is also an extra
large drip pan available as an option for the
1000-TH series ovens.
12.
Overflow may also be caused by overloading
the oven compartment. DO NOT OVERLOAD
THE OVEN
. Follow the recommended load
capacities listed in each individual procedure.
13.
For best results, many products
should be cooked on an overnight
cook-and-hold basis. Consult
individual procedures for
this recommendation.
The Alto-Shaam staff includes corporate
executive chefs who welcome questions.
You are invited to contact anyone on our
staff by phone (800.558.8744) or e-mail
through the Contact Us section of our
web site (www.alto-shaam.com) for help
with any cook and hold procedure.
NEED S
OME HE
LP
?