JLG 601S ANSI Service Manual - Manual (Page 18)

SECTION 1 - SPECIFICATIONS
1-2 – JLG Lift – 3120746
Swing System
Swing Motor Displacement - 4.62 cu. in. (75 cm[3]).
Swing Brake - Automatic spring applied hydraulically
released disc brakes.
Swing Hub Ratio - 50:1.
Hydraulic Gear Pump (at 1800 RPM)
7.9 GPM (29.90 lpm).
Pump Displacement - 1.02 cu. in. (16 cm[3]).
Clockwise Rotation.
Auxiliary Power Pump
2.6 GPM (9.84 lpm) @ 1200 PSI. (82.7 BAR.
Pump Displacement - 0.244 cu. in. (14 cm[3]).
DC Motor.
Clockwise Rotation.
Hydraulic Filter - In-line
Return - Bypass Type.
10 Microns Absolute.
Charge.
10 Microns Absolute.
Hydraulic Strainers (In Tank).
30 Microns.
1.3 PERFORMANCE DATA
Travel Speed.
4WD - 4 MPH (6.44 Km/hr.).
Gradeability.
(4WD) 45%.
Turning Radius (Outside)
2WS/4WD - 20 ft. 4.6875 in. (6.21 m).
4WS/4WD - 11 ft. 2.6875 in. (3.42 m).
Turning Radius (Inside)
2WS/4WD - 14 ft. 3.875 in. (5.25 m).
4WS/4WD - 5 ft. 3.625 in. (1.22 m).
Boom Elevation
+60 ft. 2 13/16 in. (18.36 m) -6 ft. 1 11/16 in. (1.87 m).
Machine Weight approximately
-4WD - 22,510 lbs. (10,211 kg).
Machine Height (Stowed)
8 ft. 4.75 in. (2.56 m).
Machine Length (Stowed)
Over Drive Axle - 27 ft. 8.125 in. (8.44 m).
Machine Width
2WS/4WD - 7 ft. 11.4375 in. (242 m).
4WS/4WD - 7 ft. 11.375 in. (2.42 m).
Wheel base
8 ft. 1.50 in. (2.48 m).
1.4 FUNCTION SPEEDS
Machine Orientation When Doing Speed
Tests
Lift: Telescope Retracted. Lift Up, Record Time, Lift Down,
Record Time.
Swing: Boom at Full Elevation. Telescope Retracted.
Swing the Turntable off center and stop. Swing the oppo-
site direction and start the test when the turntable is cen-
tered up. This eliminates ramp up and down on the
controller affecting times.
Telescope: Boom at Full Elevation; Telescope Retracted;
Telescope Out, Record Time. Telescope In, Record Time.
Drive (Forward/Reverse): Test should be done on a
smooth level surface. Drive Select Switch should be set to
High Engine. Start approximately 25 ft. (7.62 m) from the
starting point so that the unit is at maximum speed when
starting the test. Results should be recorded for a 200 ft.
(60.96 m) course. Drive Forward, Record Time. Drive
Reverse, Record Time.
Drive (Above Horizontal): Test should be done on a
smooth level surface. Drive Select Switch should be set to
Low Engine. The boom should be raised above horizon-
tal. Results should be recorded for a 50 ft. (15.24 m)
course. Drive Forward, Record Time. Drive Reverse,
Record Time.
Platform Rotate: Platform level and completely rotated
one direction. Rotate the opposite direction, Record Time.
Rotate the other direction, Record Time.
Articulating Jib: Platform level and centered with the
boom. Start with the Jib down. Jib Up, Record Time. Jib
Down, Record Time.